Product ID:DURA-PLATE UHS HARDENER (PART B), B62G210
MSDS Date:08/17/1998
FSC:8010
NIIN:00N092034
Status Code:A
MSDS Number: CJLZZ

SHERWIN-WILLIAMS COMPANY

101 PROSPECT AVE N W
CLEVELAND, OH 44115
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: 54636

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

0.15.

CAS: 100-51-6

RTECS: DN3150000

70.00

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 590 MG/M3;200 PPM

ACGIH TLV: 590 MG/M3;200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PHENOL, 2,4,6-TRIS(DIMETHYLAMINOMETHYL)-; (TRI

CAS: 90-72-2

RTECS: SN3500000

METHYLENE DICYCLOHEXYLAMINE

CAS: 1761-71-3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EXPOSURE MAY BE BY INHALATION AND/OR
SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF USE. TO MINIMIZE
EXPOSURE, FOLLOW RECOMMENDATIONS FOR PROPER USE, VENTILATION, &
PERSONAL PROTECTIVE EQUIPMENT. ACU TE: CAUSES BURNS ON CONTACT WITH
SKIN/EYES, & SEVERE IRRITATION OF UPPER RESPIRATORY SYSTEM. MAY
CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE MAY RESULT IN
UNCONSCIOUSNESS & POSSIBLY DEATH. S IGNS & SYMPTOMS OF
OVEREXPOSURE: HEADACHE, DIZZINESS, NAUSEA, & LOSS OF COORDINATION
ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS/SPRAY MISTS.
REDNESS & ITCHING/BURNING SENSATION MAY INDICATE EYE/E XCESSIVE
SKIN EXPOSURE. (EFTS OF OVEREXP
Explanation of Carcinogenicity:NO INGREDIENTS IN THIS PRODUCT IS AN
IARC, NTP OR OSHA LOSTED CARCINOGEN.
Effects of Overexposure:HLTH HAZ: CHRONIC: PROLONGED OVEREXPOSURE TO
SOLVENT INGREDIENTS IN SECTION 2 MAY CAUSE ADVERSE AFFECTS TO THE
NERVOUS AND REPRODUCTIVE SYSTEMS. REPORTS HAVE ASSOCIATED REPEATED
AND PROLONGED OVEREXPO SURE TO SOLVENTS WITH PERMANENT BRAIN AND
NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:MAY CAUSE ALLERGIC SKIN REACTION IN
SUSCEPTIBLE PERSONS.

First Aid:INHAL: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM AND
QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE RE-USE. EYES: FLUSH
WITH L ARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION. INGESTION: NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. DO NOT INDUCE VOMITING. GIVE SEVERAL GLASSES OF
WATER. SEEK MEIC AL ATTENTION IMMEDIATELY.

Flash Point Method:PMCC
Flash Point:=73.9C, 165.F
Lower Limits:1.8%
Upper Limits:10.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG
NOZZLES ARE PREFERABLE. WATER MAY BE USED TO COOL CLOSED CONTAINERS
TO PREVENT PRESSUR E BUILD-UP AND POSSIBLE AUTOIGNITION OR
EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:FLAMMABILITY CLASSIFICATION: COMBUSTIBLE,
FLASH ABOVE 99 AND BELOW 200 F. KEEP CONTAINERS TIGHTLY CLOSED.
ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, & OPEN FLAME.
CLOSED CONTAINERS MAY EXPLODE W HEN EXPOSED TO EXTREME HEAT.
APPLICATION TO HOT SURFACES REQUIRES SPECIAL PRECAUTIONS. DURING
EMERGENCY (SUPDAT)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.

Handling and Storage Precautions:DOL STORAGE CATEGORY: 3A. CONTENTS ARE
COMBUSTIBLE. KEEP AWAY FROM HEAT & OPEN FLAME. CONSULT NFPA CODE.
USE APPRVD BONDING & GROUNDING PROC. KEEP CNTNR CLOSED WHEN NOT IN
USE. TRANSFER ONLY TO APPRVD CNTNRS W/COMPLETE & APPROP LABELING.
DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:THIS PROD MUST BE MIXED W/OTHER COMPONENTS BEFORE
USE. BEFORE OPENING PACKAGES, READ & FOLLOW WARNING LABELS ON ALL
COMPONENTS. INTENTIONAL MISUSE BY DELIB CONC & INHALING CONTENTS
CAN BE HARMFUL/FAT AL. PREVENT CNTCT W/SKIN & EYES. USE ONLY
W/ADEQUATE VENT. PREVENT BRTHG VAP & SPRAY MIST. (SUPDAT)

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENT, WEAR PROPERLY FITTED ORGANIC
VAP/PARTICULATE RESP APPRVD BY NIOSH FOR PROT AGAINST MATERIALS IN
SECTION 2. WHEN SANDING/ABRAD ING DRIED FILM, WEAR DUST/MIST RESP
APPRVD BY NIOSH FOR DUST WHICH MAY BE GENERATED FROM THIS PRODUCT,
UNDERLYING PAINT/ABRASIVE.
Ventilation:LOC EXHST PREFERABLE. GENERAL EXHST ACCEPTABLE IF EXPOS TO
MATLS IN SECTION 2 IS MAINTAINED BELOW APPLIC EXPOS LIMITS. REFER
TO OSHA STANDARDS (SUPDAT)
Protective Gloves:RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
TO PREVENT SKIN CONTACT, WEAR PROTECTIVE CLOTHING TO COVER AS MUCH
SKIN AS POSSIBLE. USE BARRIER CREAM ON REMAINING EXPOSED SKIN.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
EXPLO HAZ: CONDITIONS OVEREXP TO DECOMP PROD MAY CAUSE HLTH HAZ. SYMPS
MAY NOT BE IMMEDIATELY APARENT. OBTAIN MED ATTN. VENT: 1910.94,
1910.107, 1910.108. OTHER PREC: THIS COATING MAY CNTN MATLS CLASS
IFIED AS NUISANCE PARTICULATES (LISTED "AS DUST" IN SECTION 2)
WHICH MAY BE PRESENT AT HAZ LEVELS ONLY (OTHER INFO)

Boiling Pt:>78.9C, 174.F
B.P. Text:174-405F
Melt/Freeze Pt:M.P/F.P Text:N.A.
Vapor Pres:SEE INGRIEDENTS
Spec Gravity:0.94
VOC Pounds/Gallon:290
VOC Grams/Liter:2.42
Viscosity:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N.A.
Percent Volatiles by Volume:30%

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:WASTE FROM THIS PRODUCT IS NOT HAZARDOUS AS
DEFINED UNDER THE RESOURCE CONSERVATION AND RECOVERY ACT (RCRA) 40
CFR 261. INCINERATE IN APPROVED FACILITY. DO NOT INCINERATE CLOSED
CONTAINER. DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL
REGULATIONS REGARDING POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

SARA Title III Information:SARA 313 (40 CFR 372. 65C) SUPPLIER
NOTIFICATION: CAS NO: 78-93-3. CHEMICAL/COMPOUND: METHYL ETHYL
KETONE. % BY WT: 8.
Federal Regulatory Information:TSCA CERTIFICATION: ALL CHEMICALS IN
THIS PRODUCT ARE LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA
INVENTORY.
State Regulatory Information:CALIFORNIA PROPOSITION 65: WARNING: THIS
PRODUCT CONTAINS A CHEMICAL(S) KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER.