Product ID:ASTROSOL ORANGE
MSDS Date:02/04/2000
FSC:6850
NIIN:01-461-0065
MSDS Number: CJPBQ

Emergency Phone: 800-255-3824 CHEM-TEL INC

Info Phone: 210-653-2060/FX2106530825

Cage: 55208

Telephone: 800-531-1088/ 210-653-2060

Cage: 55208

D-LIMONENE

CAS: 5989-27-5

RTECS: GW6360000

LD50 LC50 Mixture:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:NO DATA PROVIDED BY
RESPONSIBLE PARTY. ACUTE - INHALATION: SLIGHT HAZARD. LOW VAPOR
PRESSURE. MAY CAUSE DIZZINESS, NAUSEA, HEADACHES. SKIN CONTACT:
MODERATE HAZARD. MAY CAUSE SKIN IRRITA TION OR DERMATITIS. SKIN
ABSORPTION: LOW HAZARD. NO EVIDENCE OF SKIN ABSORPTION AT USE
DILUTION. EYE CONTACT: MODERATE HAZARD. CORROSIVE TO EYES. CHRONIC
- INHALATION: MODERATE HAZARD. MAY CAUSE DIZZI NESS, NAUSEA,
HEADACHES. SKIN: LOW HAZARD. DERMATITIS MAY RESULT FROM CHRONIC
EXPOSURE. SKIN ABSORPTION: NO HAZARD. NO EVIDENCE OF SKIN
ABSORPTION AT USE DILUTION. EYE CONTACT:NO HAZARD. PAIN WOULD PR
ECLUDE CHRONIC EFFECTS.
Explanation of Carcinogenicity:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Effects of Overexposure:INHALATION: DIZZINESS, NAUSEA, HEADACHES.
SKIN: IRRITATING. EYES: PAIN.
Medical Cond Aggravated by Exposure:NO DATA PROVIDED BY RESPONSIBLE
PARTY.

First Aid:EYES: IMMEDIATELY FLUSH WITH DIRECT STREAM OF WATER FOR AT
LEAST 15 MINUTES. SKIN: FLUSH WITH WATER, REMOVE ANY CONTAMINATED
CLOTHING, AND WASH SKIN WITH SOAP AND WATER. INHALATION: REMOVE
TO FRESH AIR. GIVE OXYGEN IF NEEDED. INGESTION: DRINK LARGE
VOLUMES OF WATER. DO NOT INDUCE VOMITING. CONSULT PHYSICIAN
IMMEDIATELY.

Flash Point Method:PMCC
Flash Point:>62.8C, 145.F
Autoignition Temp:>204.4C, 400.F
Lower Limits:2%
Upper Limits:18%
Extinguishing Media:WATER, CARBON DIOXIDE (C02).
Fire Fighting Procedures:NONE.
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:RINSE WITH WATER; PREVENT FURTHER DISCHARGE OF
MATERIAL; CONTAIN AND CLEAN UP SPILL WITH ABSORBENT.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.

Handling and Storage Precautions:DO NOT STORE WHERE PRODUCT IS EXPOSED
TO EXTREME VARIATIONS TEMPERATURE.
Other Precautions:AVOID PROLONGED SKIN CONTACT. USE IN WELL VENTILATED
AREAS. CONSULT PRODUCT BULLETIN OR TECH ORDER FOR PROPER USE.

Respiratory Protection:NONE. RESPIRATORS REQUIRED FOR CONFINED SPACES.
Ventilation:NONE.
Protective Gloves:RUBBER, CHEMICAL RESISTANT
Eye Protection:GOGGLES AND FACE SHIELD
Other Protective Equipment:RUBBER BOOTS AND APRON
Work Hygienic Practices:AVOID PROLONGED SKIN CONTACT
Supplemental Safety and Health
NO DATA PROVIDED BY RESPONSIBLE PARTY.

HCC:V4
Boiling Pt:>98.9C, 210.F
Melt/Freeze Pt:<-12.2C, 10.F
Vapor Pres:10MMHG@24C
Vapor Density:1
Spec Gravity:1.0
VOC Pounds/Gallon:415
pH:10
Evaporation Rate & Reference:0.5 (H20=1)
Solubility in Water:PARTIALLY SOLUBLE
Appearance and Odor:AMBER THIN LIQUID, ORANGE ODOR
Percent Volatiles by Volume:55%

STRONG OXIDIZERS AND REACTIVE METALS
Stability Condition to Avoid:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Hazardous Decomposition Products:NO KNOWN HAZARDOUS PRODUCTS FROM
DECOMPOSITION

Waste Disposal Methods:AS IS THE PRODUCT IS NOT CONSIDERED A HAZARDOUS
WASTE BY EPA GUIDELINES. CONSULT LOCAL, STATE, AND FEDERAL
REGULATORY AGENCIES FOR PROPER DISPOSAL.

Toxicological Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:PRODUCT IS 84.5% BIODEGRADABLE IN 26 DAYS BASED ON EPA
763.3100.

Transport Information:NOT REGULATED.

SARA Title III Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Federal Regulatory Information:ALL MATERIALS USED IN THE MANUFACTURING
HAVE BEEN CERTIFIED BY THEIR MANUFACTURER AS BEING ON OR EXEMPT
FROM THE CURRENT TOXIC SUBSTANCE CONTROL ACT (TSCA) INVENTORY.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.