Product ID:HENDERSON MARINE DECK COATING, XZ-SERIES (ALL COLORS)
MSDS Date:06/10/1998
FSC:8010
NIIN:00N091799
Status Code:A
MSDS Number: CJPFX

KELLY-MOORE PAINT CO, INC

987 COMMERCIAL ST
SAN CARLOS, CA 94070
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 650-592-8337

Preparer: GEORGE HUNT

Cage: 0Y837

KELLY-MOORE PAINT CO INC

SAN CARLOS, CA 94070 US

Telephone: 650-592-8337

Cage: 0Y837

NONE @ 68F

CAS: 14464-46-1

RTECS: VV7325000

OSHA PEL see Table Z-3

ACGIH TLV: 0.05 MG/M3

0.04 MM HG @ 68F

CAS: 25265-77-4

RTECS: UF6000000

OSHA PEL N/K

ACGIH TLV: N/K

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: DIZZINESS, HEADACHE, CONFUSION,
IRRITATION TO UPPER RESPIRATORY TRACT, SKIN AND EYE IRRITATION.
CHRONIC: PROLONGED AND/OR REPEATED EXPOSURE TO HIGH CONCENTRATIONS
OF RESPIRABLE (AIRBORNE) CRYST ALLINE SILICA DUSTS AS MAY BE
GENERATED BY SANDING OR GRINDING OF DRIED PAINTS AND OTHER BUILDING
MATERIALS WITHOUT WEARING PROPER RESPIRATORY PROTECTION CAN CAUSE
CANCER OR SILICOSIS, A NON-CANCEROUS DISEASE THAT CAN RESULT IN
SUBSTANTIAL IMPAIRMENT OF BREATHING FUNCTION.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-CRISTOBALITE: IARC
MONOGRAPHS, VOLUME 68, 1998: GROUP 1. NTP 8TH ANNUAL REPORT ON
CARCINOGENS, 1998: REASONABLY ANTICIPATED TO BE HUMAN CARCINOGEN.
HUMAN: LUNG.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN. SEE YOUR PHYSICIAN FOR
SPECIFIC MEDICAL OPINION REGARDING YOUR CONDITION.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT
PHYSICIAN. EYES: FLUSH WITH LARGE VOLUMES OF WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION. SKIN: WIPE OFF WITH A RAG. WASH
THOROUGHL Y WITH SOAP AND WATER. INGESTION: CONSULT HOSPITAL
EMERGENCY ROOM OR POISON CONTROL CENTER IMMEDIATELY.

Flash Point:NONE
Extinguishing Media:NOT APPLICABLE. USE MEDIA SUITABLE FOR SURROUNDING
FIRE .
Fire Fighting Procedures:NONE. WEAR NIOSH APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILD-UP OF STEAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
FLAMMABILITY CLASSIFICATION: NOT REGULATED.

Spill Release Procedures:VENTILATE AREA TO PREVENT BUILD-UP OF VAPORS.
FOR SMALL SPILLS, SOAK UP WITH ABSORBENT. FOR LARGER SPILLS, DIKE
AREA WITH ABSORBENT MATERIAL AND SCOOP UP LIQUIDS.

Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS
AWAY FROM HEAT AND FLAME.
Other Precautions:THE CONTROL MEASURES SHOULD BE FOLLOWED WHEN YOU SAND
THIS PRODUCT AND MOST OTHER PAINTS AND BUILDING MATERIALS SUCH AS
SPACKLES AND DRY WALL COMPOUNDS.

Respiratory Protection:USE A PARTICLE MASK (NIOSH TC-21C) TO AVOID
BREATHING SPRAY MIST/SANDING DUST IF LOCAL VENTILATION IS ADEQUATE
TO KEEP CONCENTRATIONS WITHIN ACCEPTABLE (TLV) LIMITS. IF LOCAL
VENTILATION IS NOT SUFFIC IENT/WHERE EXPOSURE LIMITS ARE EXCEEDED,
WEAR A SUITABLE, PROPERLY FITTED RESPIRATOR (NIOSH TC-23C OR
BETTER) FOR ORGANIC VAPORS WITH A DUST FILTER AS NEEDED.
Ventilation:LOCAL CROSS-VENTILATION OR MECHANICAL EXHAUST SUFFICIENT TO
KEEP ALL HAZARDOUS CONCENTRATIONS BELOW PRESCRIBED LIMITS.
Protective Gloves:RECOMMENDED IF NECESSARY TO PVNT EXTENDED EXPOS. WEAR
IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
SHOWER .
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
PHYSICAL/CHEMICAL PROPERTIES: DENSITY: 11-13 LBS/GAL; VOC OF MATERIAL
(POUNDS PER GALLON): 0.5; VOC (GRAMS PER LITER LESS WATER): <125;
VAPOR DENSITY: LIGHTER THAN AIR (WATER VAPOR).

Boiling Pt:=100.C, 212.F
B.P. Text:(WATER)
Vapor Pres:SEE INGREDIENTS
Vapor Density:SUP DAT
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:56 - 59

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING.

Waste Disposal Methods:DISCARD IN LANDFILL IN SEALED CONTAINERS AWAY
FROM HEAT AND FLAME AND IN ACCORDANCE WITH LOCAL REGULATIONS.
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS
.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Federal Regulatory Information:HAZARD CLASSIFICATION: OSHA HEALTH
HAZARD: TOXIC. OSHA PHYSICAL HAZARD: NOT APPLICABLE.
State Regulatory Information: