Product ID:80 2000 S S S
MSDS Date:05/12/1998
FSC:8010
NIIN:00N093465
Status Code:A
MSDS Number: CJYGW

VALSPAR CORP

1101 THIRD ST SOUTH
MINNEAPOLIS, MN 55415
US

Emergency Phone: 800-228-5635

Info Phone: 612-332-7371

Cage: 13418

VALSPAR CORPORATION

MINNEAPOLIS, MN 55415 US

Telephone: 612-332-7371/800-228-5635

Cage: 13418

SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPH.; (VM&P NAPHTHA)

CAS: 64742-89-8

ACGIH TLV: 420 PPM TWA

OCTADECANOIC ACID, ZINC SALT; (ZINC STEARATE)

CAS: 557-05-1

RTECS: ZH5200000

OSHA PEL 15 MG/M3

KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS)

CAS: 64742-47-8

RTECS: OA5504000

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 200 PPM

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF INHALED. MAY AFFECT
BRAIN, NERVOUS SYSTEM OR RESPIRATORY SYSTEM, CAUSING DIZZINESS,
HEADACHE, NAUSEA OR RESPIRATORY IRRITATION. OVEREXPOSURE TO
INGREDIENTS IN THIS PRODUCT MAY CAUSE NOSE AND THROAT IRRITATION,
EYE IRRITATION, SKIN IRRITATION, CENTRAL NERVOUS SYSTEM DEPRESSION,
CORNEAL INJURY OR EYE DAMAGE. CHRONIC: POSSIBLE BIRTH DEFECTS
HAZARD. CONTAINS INGREDIENTS WHICH MAY CAU SE BIRTH DEFECTS BASED
ON ANIMAL DATA. NOTICE: REPORTS HAVE ASSOCIATED REPEATED AND
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT
BRAIN AND NERVOUS SYTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
(EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: CONCENTRATING AND INHALING THE
CONTENTS MAY BE HARMFUL OR FATAL. CONTAINS INGREDIENTS WHICH MAY
CAUSE LIVER DAMAGE, KIDNEY DAMAGE. NOTE: TOLUENE APPEARS ON THE
NAVY LIST OF OCCUPATIONAL CHEM ICAL REPRODUCTIVE HAZARDS. SEEK
CONSULTATION FROM APPROPRIATE HEALTH PROFESSIONALS CONCERNING THE
LATEST HAZARD LIST INFORMATION AND SAFE HANDLING AND EXPOSURE
INFORMATION .
Medical Cond Aggravated by Exposure:ANY RESPIRATORY OR SKIN CONDITION.

First Aid:EYES: FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES AND GET MEDICAL ATTENTION. SKIN: WASH THOROUGHLY WITH SOAP
AND WATER. INHALATION: IF AFFECTED BY INHALATION OF VAPOR OR SPRAY
MIST, REMOVE TO FRESH AIR. INGESTION: IF SWALLOWED, GET MEDICAL
ATTENTION IMMEDIATELY.

Flash Point Method:TCC
Flash Point:=16.1C, 61.F
Autoignition Temp:Autoignition Temp Text:N/AV
Lower Limits:1%
Upper Limits:7%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, AND/OR WATER
FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . CONTAINERS EXPOSED TO FIRE SHOULD BE KEPT COOL WITH
WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE. SENSITIVITY TO IMPACT: NONE.
SENSITIVITY TO STATIC DISCHARGE: NOT AVAILABLE.

Spill Release Procedures:VENTILATE AREA. AVOID BREATHING OF VAPORS. USE
NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS OR AIRMASK FOR
LARGE SPILLS IN A CONFINED AREA. ELIMINATE IGNITION SOURCES. REMOVE
WITH INERT ABSORBENT AND NON-SPARKING TOOLS. AVOID CONTACT WITH
EYES.

Handling and Storage Precautions:CONTAINERS SHOULD BE GROUNDED/BONDED
WHEN POURING. AVOID FREE FALL OF LIQUID IN EXCESS OF A FEW INCHES.
KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAMES. KEEP CONTAINER CLOSED
WHEN NOT IN USE. DO NOT STORE ABOVE 120F (49C).
Other Precautions:BASED ON THE PRODUCT FLASH POINT AND VAPOR PRESSURE,
SUITABLE STORAGE SHOULD BE PROVIDED I/A/W OSHA REGULATION
1910.106/ONTARIA OH&S REGULATION 851 SECTION 22. EMPTY CONTAINERS
MAY CONTAIN PRODUCT RES IDUE, INCLUDING FLAMMABLE OR EXPLOSIVE
VAPORS. DO NOT CUT, PUNCTURE OR WELD ON OR NEAR CONTAINER. AL L
LABEL (SUPP DATA)

Respiratory Protection:UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST
LEVELS ABOVE APPLICABLE LIMITS, NO RESPIRATOR IS REQUIRED. IF
RESPIRATOR IS REQUIRED, THE APPROPRIATE, PROPERLY FITTED, NIOSH
APPROVED RESPIRATOR SHOULD B E WORN DURING APPLICATION. FOLLOW
RESPIRATOR MANUFACTURERS DIRECTIONS FOR RESPIRATOR USE.
Ventilation:REQUIRED FOR SPRAYING OR IN A CONFINED AREA, VENTILATION
EQUIPMENT SHOULD BE EXPLOSION PROOF. ELIMINATE IGNITION SOURCES.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . USUAL CLOTHING FOR PAINTING OPERATIONS.
Supplemental Safety and Health
PHYSICAL DATA: COEFFICIENT OF WATER/OIL DISTRIBUTION: NOT AVAILABLE.
VOC: 4.99 LBS/GAL; 598 G/L (THEORETICAL). -- OTHER PREC: WARNINGS
MUST BE OBSERVED UNTIL THE CONTAINER HAS BEEN CLEANED OR RECONDIT
IONED.

Boiling Pt:=110.C, 230.F
Vapor Pres:28 MM HG @ 70F (21C)
Vapor Density:5.1(AIR=1)
Spec Gravity:0.83
VOC Pounds/Gallon:598
pH:NOT AVAILABLE
VOC Grams/Liter:4.99
Evaporation Rate & Reference:2.0 (BUTYL ACETATE=1)
Solubility in Water:NO
Appearance and Odor:NORMAL FOR A COATING PRODUCT.
Percent Volatiles by Volume:78.40

Stability Indicator/Materials to Avoid:YES
NOT APPLICABLE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:HALIDES, CARBON DIOXIDE/MONOXIDE.

Waste Disposal Methods:DISPOSE IN CHEMICAL DISPOSAL AREA OR IN A MANNER
THAT COMPLIES WITH LOCAL, STATE, PROVINCIAL AND FEDERAL
REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

SARA Title III Information:ZINC STEARATE AND TOLUENE ARE REPORTABLE
UNDER SECTION 313 OF SARA TITLE III.
Federal Regulatory Information:ALL COMPONENTS OF THIS PRODUCT ARE IN
COMPLIANCE WITH U.S. TSCA CHEMICAL SUBSTANCE INVENTORY
REQUIREMENTS.
State Regulatory Information: