Product ID:PURPLE PRIMER NSF,30757
MSDS Date:04/01/1999
FSC:NIIN:Submitter:N EN
Status Code:A
MSDS Number: CKBZK

OATEY CO

4700 WEST 160TH STREET
CLEVELAND, OH 44135
US

Emergency Phone: 303-623-5716

Info Phone: 216-267-7100

Cage: 53472

OATEY CO

35906 CLEVELAND, OH 44135 US

Telephone: 216-267-7100/303-623-5716

Cage: 53472

METHYL ETHYL KETONE

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 590 MG/M3;200 PPM

ACGIH TLV: 590 MG/M3;200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

735 MG/M3 STEL (M).

CAS: 109-99-9

RTECS: LU5950000

OSHA PEL 590 MG/M3;200 PPM

ACGIH TLV: 590 MG/M3;200 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CYCLOHEXANONE

CAS: 108-94-1

RTECS: GW1050000

OSHA PEL 200 MG/M3;50 PPM

ACGIH TLV: 100 MG/M3;25 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

1200 MG/M3; 500 PPM (M) & 1200 MG/M3;

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 2400 MG/M3;1000 PPM

ACGIH TLV: 1780 MG/M3;750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

VIOLET DYE

CAS: 81-48-1

RTECS: CB7700000

RED DYE

CAS: 4477-79-6

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE IRRITATION OF
MUCOUS MEMBRANES, NOSE AND THROAT, HEADACHE, DIZZINESS, NAUSEA,
NUMBNESS OF EXTREMITIES AND NARCOSIS IN HIGH CONCENTRATIONS. HAS
CAUSE CENTRAL NERVOUS SYSTEM DEPRES SION AND LIVER DAMAGE IN
ANIMALS, AND CONCENTRATIONS OF 1000-3000 PPM CAUSED RETARDATION OF
FETAL DEVELOPMENT IN RATS. SKIN: CHRONIC CONTACT MAY LEAD TO
IRRITATION AND DERMATITIS. CHRONIC EXPOSURE TO VAPORS OF HIGH
CONCENTRATION MAY CAUSE DERMATITIS. MAY POSSIBLE BE ABSORBED
THROUGH SKIN. EYE: VAPORS OR DIRECT CONTACT MAY CAUSE IRRITATION.
INGESTION: MAY BE ASPIRATED INTO LUNGS OR CAUSE SYSTEMIC E FFECTS
DESCRIBED UNDER (EFTS OF OVEREXP)
Explanation of Carcinogenicity:KNOWN HAZARDS UNDER 29 CFR 1910.1200:
CARCINOGEN (NTP/IARC/OSHA): NO.
Effects of Overexposure:HLTH HAZ: INHALATION. TARGET ORGANS: EYE, SKIN,
LUNG, CENTRAL NERVOUS SYSTEM.

First Aid:SKIN: FLUSH WITH WATER THEN WASH THORO WITH SOAP & WATER.
REMOVE CONTAMINATED CLOTHING & WASH BEFORE RE-USE. CALL POISON
CONTROL CENTER OR MD IF IRRIT PERSISTS. EYES: FLUSH WITH WATER FOR
AT LEAST 15 MINUTES & CALL POISON CONTROL CENTER OR MD IF IRRIT
PERSISTS. INHAL: MOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. IF NOT BREATHING, GIVE ARTF RESP. KEEP VICTIM QUIET & WARM.
CALL POISON CONTROL CENTER OR MD IMMED. INGEST: DRINK WATER & CALL
POISON CONTROL CENTER OR MD IMMED. AVOID ALCOHOLIC BEVERAGES. NEVER
GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO NOT INDUCE
VOMITING.

Flash Point Method:PMCC
Flash Point:>-17.6C, 0.F
0-5F
Lower Limits:1%
Upper Limits:10%
Extinguishing Media:FOR SMALL FIRES: USE DRY CHEMICAL, CO*2, WATER OR
FOAM EXTINGUISHER. FOR LARGE FIRES: EVACUATE AREA AND CALL FIRE
DEPARTMENT IMMEDIATELY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NFPA HAZARD SIGNAL: HEALTH - 2;
REACTIVITY - 1; FLAMMABILITY - 3.

Spill Release Procedures:VENTILATE AREA, STOP LEAK IF IT CAN BE DONE
WITHOUT RISK. TAKE UP WITH SAND, EARTH, OR OTHER NON-COMBUSTIBLE
MATERIAL.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS AND
FLAMES; STORE IN COOL, DRY PLACE.
Other Precautions:CONTAINERS, EVEN EMPTIES WILL RETAIN RESIDUE AND
VAPORS.

Respiratory Protection:NIOSH APPROVED CANISTER RESPIRATOR IN ABSENCE OF
ADEQUATE VENTILATION.
Ventilation:GEN MECH:EXHST VENT CAPABLE OF MAINTAINING EMISSIONS AT THE
POINT OF USE BELOW PEL. LOC EXHST:OPEN DOORS & WINDOWS. IS USED IN
ENCLOSED AREA, USE EXHAUST FANS.
Protective Gloves:RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Supplemental Safety and Health
PHYSICAL AND CHEMICAL PROPERTIES: WILL DISSOLVE IN: WATER, ORGANIC
SOLVENTS.

Boiling Pt:=78.9C, 174.F
Vapor Pres:70 MMHG @ 20C
Vapor Density:2.5(AIR=1)
Spec Gravity:0.807 +/- 0.01
Evaporation Rate & Reference:5.5-8.0 (BUTYL ACETATE=1)
Solubility in Water:28 PARTS
Appearance and Odor:PURPLE LIQUID; SHARP, ETHER ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZING MATERIALS, ALKALIS, CHLORINATED INORGANICS (POTASSIUM,
CALCIUM AND SODIUM HYPOCHLORITE), COPPER OR COPPER ALLOYS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE/CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS. EPA HAZARDOUS WASTE ID NUMBER: U-213 & F-005. EPA
HAZARD WASTE CLASS: IGNITABLE WASTE/TOXIC WASTE.

Toxicological Information:TETRAHYDROFURAN WARNING: THE NTP HAS REPORTED
THAT EXPOS OF MICE & RATS TO TETRAHYDROFURAN (THF) VAP LEVELS UP TO
1800 PPM 6 HR/DAY, 5 DAYS/WEEK FOR THEIR LIFETIME CAUSED INCR
INCIDENCE OF KIDNEY TUMO RS IN MALE RATS & LIVER TUMORS IN FEMALE
MICE. THE SIGNIFICANCE OF THESE FINDINGS FOR HUMAN HLTH ARE UNCLEAR
AT THIS TIME, & MAY BE RELATED TO "SPECIES SPECIFIC" EFTS. ELEVATED
INCIDENCES OF TUMORS IN HUMANS HAVE NOT BEEN REPORTED FOR THF. THF
IS NOT LISTED AS CARCIN BY NTP, IARC/OSHA. ONE THF VENDOR HAS REC
REDUCTION IN "ACCEPT EXPOS LIM" FROM 200 PPM TO 25 PPM, 8 & 12 HR
TIME WEIGHTED AVG.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT PROPER SHIPPING NAME: CONSUMER COMMODITY
ORM-D (FOR GALLONS: FLAMMABLE LIQUID, N.O.S. METHYL ETHYL KETONE,
CYCLOHEXANONE) 3, UN1993, PG II, PRIMER-006. DOT HAZARD CLASS:
FLAMMABLE LIQUID. SHIPPING ID NUMBER: 149980-2 (GALLONS ONLY).

SARA Title III Information:METHYL ETHYL KETONE: LISTED UNDER SECTION
313.
Federal Regulatory Information:KNOWN HAZARDS UNDER 29 CFR 1910.1200:
FLAMMABLE LIQUID; IRRITANT; SKIN HAZARD; EYE HAZARD; TOXIC AGENT;
KIDNEY TOXIN; REPRODUCTIVE TOXIN; NERVOUS SYSTEM TOXIN; LUNG TOXIN;
LIVER TOXIN.
State Regulatory Information: