Product ID:5957C
MSDS Date:06/01/1997
FSC:1560
NIIN:01-252-4991
Status Code:A
MSDS Number: CKDBG

ENGINEERED FABRICS CORPORATION

669 GOODYEAR STREET
ROCKMART, GA 30153
US

Emergency Phone: 216-379-8562

Info Phone: 706-684-7855

Preparer: WILLIAM R. RITTER

Cage: 56221

ENGINEERED FABRICS CORPORATION

548 ROCKMART, GA 30153 US

Telephone: 706-684-7855

Cage: 56221

DIETHYLTOLUENEDIAMINE

CAS: 68479-98-1

2-BUTANONE

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 590 MG/M3;200 PPM

ACGIH TLV: 590 MG/M3;200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: CONTACT WITH THE EYE CAN CAUSE
SEVERE IRRITATION, REDNESS, TEARING AND BLURRED VISION. PROLONGED
EXPOSURE MAY CAUSE SKIN IRRITATION. CHRONIC: IN RARE INSTANCES,
SENSITIZATION TO DIETHYLTOLUENED IAMINE HAS BEEN REPORTED TO OCCUR
IN HUMANS. A TWO YEAR FEEDING STUDY IN RATS SHOWED DETDA CAUSED
EFFECTS IN PANCREAS, LIVER, THYROID AND EYES. AN INCREASE IN
NUMBER OF TUMORS IN THE LIVER & THYROID OF MALE RATS & IN THE
LIVER & POSSIBLY MAMMARY GLANDS OF FEMALE RATS WAS FOUND.
Effects of Overexposure:SEVERE IRRITATION, REDNESS, TEARING AND BLURRED
VISION. SKIN IRRITATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING MEDICAL CONDITIONS:
PRE-EXISTING EYE, SKIN AND RESPIRATORY CONDITIONS MAY BE AGGRAVATED
BY EXPOSURE TO THIS PRODUCT.

First Aid:INHALATION: IF AFFECTED, REMOVE INDIVIDUAL TO FRESH AIR. IF
BREATHING IS DIFFICULT, ADMINISTER OXYGEN. IF BREATHING HAS
STOPPED, GIVE ARTIFICIAL RESPIRATION. KEEP WARM,QUIET AND GET
MEDICAL ATTENTION. EYE: FLUSH WITH LARGE AMOUNTS OF WATER, LIFTING
UPPER AND LOWER LIDS OCCASIONALLY. GET MEDICAL ATTENTION. SKIN:
THOROUGHLY WASH EXPOSED AREA WITH SOAP & WATER. REMOVE CONTAMINATED
CLOTHING. LAUNDER C ONTAMINATED CLOTHING BEFORE REUSE. INGESTION:
GIVE TWO GLASSES OF WATER & INDUCE VOMITING BY STICKING FINGER DOWN
THROAT. CALL A PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.

Flash Point Method:CC
Flash Point:=-8.7C, 16.F
MEK
Lower Limits:1.4@200F,MEK
Upper Limits:11.4@200FMEK
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:TOXIC GASES AND VAPORS MAY BE RELEASED BY
THERMAL DECOMPOSITION. FIREFIGHTERS SHOULD USE A SELF-CONTAINED
BREATHING APPARATUS WITH A FULL FACEPIECE UNDER POSITIVE PRESSURE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND OR MAY BE MOVED BY VENTILATION AND BE
IGNITED AT LOCATIONS DISTANT FROM THE MATERIAL HANDLING POINT.

Spill Release Procedures:REMOVE ALL IGNITION SOURCES. VENTILATE AREA.
WEAR PERSONAL PROTECTIVE EQUIPMENT AS NECESSARY. DIKE OR CONTAIN
SPILL WITH ABSORBANT OR OTHER AVAILABLE MATERIALS. DO NOT ALLOW
SPILL TO DISCHARGE INTO ST ORM OR SANITARY SEWER. PUMP OR BAIL MATL
BACK INTO ORIGINAL CONTAINER OR CLEAN, EMPTY CONTAINER OF SAME DOT
SPECIFICATION. MATERIALS USED IN CLEAN UP PROCESS BE DISCARDED &
CONSIDERED HAZARDOUS WASTE.

Handling and Storage Precautions:THE STORAGE AREA SHOULD BE WELL
VENTILATED. STORE AWAY FROM SOURCES OF HEAT AND OPEN FLAMES. KEEP
CONTAINER CLOSED WHEN NOT IN USE.

Respiratory Protection:IF WORKPLACE CONCENTRATIONS EXCEED THE
RECOMMENDED TLV'S, USE A NIOSH/MSHA-APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. IN ACCORDANCE WITH 29 CFR 1910.134 USE EITHER AN
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AIR-PURIFYING RESPIRATOR FOR
ORGANIC VAPORS.
Ventilation:PROVIDE ADEQUATE EXPLOSION-PROOF VENTILATION TO MAINTAIN
VAPORS BELOW THE TLV'S .
Protective Gloves:BUTYL
Eye Protection:CHEMICAL GOGGLES. CONTACT LENSES SHOULD NOT BE WORN.
Other Protective Equipment:WEAR IMPERVIOUS PROTECTIVE CLOTHING TO
PREVENT SKIN CONTACT.
Supplemental Safety and Health
KEY1:F2.

HCC:F2
Vapor Density:NOT ESTABL
Spec Gravity:0.90
Solubility in Water:SOLUBLE IN WATER
Appearance and Odor:CLEAR LIQUID. ODOR: AMINE
Percent Volatiles by Volume:56

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CO, CO2, NOX.

Waste Disposal Methods:COMPLY WITH ALL FEDERAL, STATE AND LOCAL LAWS
AND REGULATIONS APPLICABLE TO PACKAGING, MANIFESTING, TRANSPORTING
AND DISPOSING OF HAZARDOUS WASTE. EPA RCRA ID NUMBER: D001, F005
REFERENCE 40 CFR 261 .

Transport Information:FLAMMABLE LIQUID, NOS (CONTAINS METHYL ETHYL
KETONE), UN1993, PG II.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.