Product ID:FS-3730-2
MSDS Date:10/15/1997
FSC:6850
NIIN:01-420-0216
MSDS Number: CKDCK

NUSIL TECHNOLOGY

1050 CINDY LN
CARPINTERIA, CA 93013-2906
US

Emergency Phone: 805-684-8780

Info Phone: 805-684-8780

Preparer: NOT PROVIDED.

Cage: 5U206

NUSIL TECHNOLOGY

CARPINTERIA, CA 93013-2906 US

Telephone: 805-684-2365

Cage: 5U206

SILICA,AMORPHOUS,TREATED

CAS: 67762-90-7

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

ETHYLTRIACETOXYSILANE

CAS: 17689-77-9

OSHA PEL NOT ESTABLISHED.

ACGIH TLV: NOT ESTABLISHED.

ACETIC ACID (MAY BE GIVEN OFF DURING CURE)

CAS: 64-19-7

RTECS: AF1225000

Fraction By Weight: TRACE

OSHA PEL 25 MG/M3;10 PPM

ACGIH TLV: 25 MG/M3;10 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:NOT PROVIDED.
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SWALLOWING: MODERATELY TOXIC. MAY
CAUSE IRRITATION OF MOUTH, THROAT, ESOPHAGUS AND STOMACH, WITH
NAUSEA, ABDOMINAL AND CHEST PAIN, VOMITING, DIARRHEA, DIZZINESS,
FAINTNESS, WEAKNESS, DROWSINESS AND CO LLAPSE. ASPIRATION INTO
LUNGS MAY RESULT IN LUNG INJURY. SKIN ABSORPTION: MAY OCCUR.
INHALATION: OVEREXPOSURE TO HIGH CONCENTRATION OF VAPOR MAY RESULT
IN INHALATION OF HARMFUL AMOUNTS OF MATERIAL. SK IN: MAY CAUSE
IRRITATION, REDNESS, SWELLING AT SITE OF CONTACT. EYE: CAUSES
SEVERE IRRITATION, DISCOMFORT OR PAIN, EXCESS BLINKING AND TEARING,
REDNESS AND SWELLING OF CONJUNCTIVA. CHRONIC: RESPIRABLE PARTICLES
MAY CAUSE LUNG INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:MAY CAUSE IRRITATION OF MOUTH, THROAT,
ESOPHAGUS AND STOMACH, WITH NAUSEA, ABDOMINAL AND CHEST PAIN,
VOMITING, DIARRHEA, DIZZINESS, FAINTNESS, WEAKNESS, DROWSINESS AND
COLLAPSE. ASPIRATION INTO LUNGS MAY RESULT IN LUNG INJURY.
OVEREXPOSURE TO HIGH CONCENTRATION OF VAPOR MAY RESULT IN
INHALATION OF HARMFUL AMOUNTS OF MATERIAL. SKIN CONTACT MAY CAUSE
IRRITATION, REDNESS, SWELLING. EYE CONTACT CAUSES SEVERE
IRRITATION, DISCOMFORT OR PAIN, EXCESS BLINKING AND TEARING,
REDNESS AND SWELLING OF CONJUNCTIVA.
Medical Cond Aggravated by Exposure:BECAUSE OF ITS' IRRITATING AND
DEFATTING PROPERTIES, THIS MATERIAL MAY AGGRAVATE AN EXISTING
DERMATITIS. BREATHING OF VAPOR OR MIST MAY AGGRAVATE ASTHMA AND
INFLAMMATORY OR FIBROTIC PULMONARY DISEASE.

First Aid:SWALLOWING: IF PATIENT IS FULLY CONSCIOUS, GIVE TWO GLASSES
OF WATER. OBTAIN MEDICAL ATTENTION. SKIN: IMMEDIATELY FLUSH SKIN
WITH PLENTY OF WATER WHILE REMOVING CONTAMINATED CLOTHING AND
SHOES. OBTAIN MEDICAL ATTENTION. WASH CLOTHING BEFORE WEARING
AGAIN. DISCARD SHOES. INHALATION: REMOVE TO FRESH AIR. GIVE
ARTIFICIAL RESPIRATION IF NOT BREATHING. OXYGEN MAY BE GIVEN BY
QUALIFIED PERSONNEL IF BREA THING IS DIFFICULT. OBTAIN MEDICAL
ATTENTION. EYES: IMMEDIATELLY FLUSH EYES WITH WATER AND CONTINUE
WASHING FOR AT LEAST 15 MINUTES. OBTAIN MEDICAL ATTENTION WITHOUT
DELAY, PREFERABLY FROM AN OPHTHALM OLOGIST.

Flash Point Method:COC
Flash Point:=135.C, 275.F
Extinguishing Media:USE WATER SPRAY, CARBON DIOXIDE, DRY CHEMICAL.
ALCOHOL-TYPE OR UNIVERSAL-TYPE FOAMS APPLIED BY MANUFACTURER'S
RECOMMENDED TECHNIQUE.
Fire Fighting Procedures:DO NOT SPRAY A SOLID STREAM OF WATER OR FOAM
DIRECTLY INTO A POOL OF HOT, BURNING LIQUID AS THIS MAY CAUSE
FROTHING, AND MAY INTENSIFY THE FIRE. USE SELF-CONTAINED BREATHING
APPARATUS WHEN FIGHTING FI RE IN AN ENCLOSED AREA.
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:COVER SPILL WITH ABSORBENT MATERIAL. TRANSFER
TO A SUITABLE CONTAINER FOR DISPOSAL.

Handling and Storage Precautions:DANGER! MAY CAUSE EYE AND SKIN
IRRITATION. DO NOT GET ON SKIN OR CLOTHING. HARMFUL IF INHALED.
AVOID BREATHING VAPOR/MIST. HARMFUL IF ABSORBED THROUGH SKIN. KEEP
CONTAINER CLOSED. ASPIRATION MAY CAUSE LUNG DAMGE. USE WITH
ADEQUATE VENTILATION. DO NOT GET IN EYES. WASH THOROUGHLY AFTER
HANDLING.
Other Precautions:NOTE: DO NOT INDUCE VOMITING. STORE BELOW 90F (32C).
HMIS FORMAT: HEALTH-2, FLAMMABILITY-1, REACTIVITY-0.

Respiratory Protection:USE NIOSH APPROVED RESPIRATOR OF SELF-CONTAINED
BREATHING APPARATUS AS NEEDED TO MAINTAIN PERSONNEL EXPOSURE BELOW
ESTABLISHED OCCUPATIONAL EXPOSURE VALUES.
Ventilation:GENERAL (MECHANICAL) ROOM VENTILATION WITH LOCAL
VENTILATION AS NEEDED TO MAINTAIN EXPOSURE BELOW ESTABLISHED
OCCUPATION EXPOSURE VALUES.
Protective Gloves:USE ACID RESISTANT GLOVES.
Eye Protection:USE SAFETY GLASSES.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:NOT PROVIDED.
Supplemental Safety and Health
NOTE TO PHYSICIAN: ANY MATERIAL ASPIRATED DURING VOMITING MAY CAUSE
LUNG INJURY. THEREFORE, EMESIS SHOULD NOT BE INDUCED MECHANICALLY
OR PHARMACOLOGICALLY. IF IT IS NECESSARY TO EVACUATE STOMACH CONTE
NTS, THIS SHOULD BE DONE BY MEANS LEAST LIKELY TO CAUSE ASPIRATION
(E.G., GASTRIC LAVAGE AFTER ENDOTRACHEAL INTUBATION)

HCC:V5
NRC/State Lic Num:NOT RELEVANT.
Decomp Temp:Decomp Text:NOT PROVIDED.
Vapor Pres:5 MMHG@77F
Spec Gravity:1.40
pH:NOT RELEVANT.
Viscosity:NOT PROVIDED.
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK THICK FLUID. ACETIC ACID ODOR.
Percent Volatiles by Volume:NOT PROVIDED
Corrosion Rate:NOT PROVIDED.

Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZING SOURCES.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:BURNING CAN PRODUCE CARBON MONOXIDE,
CARBON DIOXIDE, OXIDES OF SILICON AND HYDROCARBONS. CARBON MONOXIDE
IS HIGHLY TOXIC IF INHALED; CARBON DIOXIDE IN SUFFICIENT
CONCENTRATIONS CAN ACT AS AN ASPHYXIANT.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, AND LOCAL REGULATIONS.

Toxicological Information:THIS PRODUCT CONTAINS < 120 G/LITER VOC'S.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NOT PROVIDED.

Transport Information:NOT REGULATED.

SARA Title III Information:COMPREHENSIVE ENVIRONMENTAL RESPONSE,
COMPENSATION AND LIABILITY ACT OF 1980 (CERCLA) REQUIRES
NOTIFICATION OF THE NATIONAL RESPONSE CENTER OF RELEASE OF
QUANTITIES OF HAZARDOUS SUBSTANCES EQUAL TO OR GREATER THAN THE
REPORTABLE QUANTITIES (RQ'S) IN 40 CFR 302.4. COMPONENTS PRESENT IN
THIS PRODUCT AT A LEVEL WHICH COULD REQUIRE REPORTING UNDER THE
STATUTE ARE: ACETIC ACID 64-19-7 TRACE.
Federal Regulatory Information:TSCA INVENTORY STATUS: THE INGREDIENTS
OF THIS PRODUCT ARE LISTED ON, OR ARE EXEMPT FROM LISTING ON, THE
TSCA INVENTORY. EPA HAZARD CATEGORIES: IMMEDIATE HEALTH HAZARD AND
DELAYED HEALTH HAZARD.
State Regulatory Information:CALIFORNIA PROPOSITION 65: THIS PRODUCT
CONTAINS NO LEVELS OF LISTED SUBSTANCES, WHICH THE STATE OF
CALIFORNIA HAS FOUND TO CAUSE CANCER, BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM, WHICH WOULD REQUIRE A WARNING UNDER THE
STATUTE. MASSACHUSETTS 105 CMR 670.000 RIGHT-TO-KNOW, SUBSTANCE
LIST (MSL): HAZARDOUS SUBSTANCES AND EXTRAORDINARY HAZARDOUS
SUBSTANCES ON THE MSL MUST BE IDENTIFIED WHEN PRESENT I N PRODUCT.
COMPONENTS PRESENT IN THIS PRODUCT AT A LEVEL WHICH COULD REQUIRE
REPORTING UNDER THE STA TUTE ARE: ACETIC ACID, 64-19-7, TRACE. SAME
FOR PENNSYLVANIA RIGHT-TO-KNOW HAZARDOUS SUBSTANCE LIST.