Product ID:MIL-L-81352A #17875 WHITE 700W03
MSDS Date:11/25/1997
FSC:8010
NIIN:00-935-6608
Status Code:A
MSDS Number: CKJNR

GRIGGS PAINT

3602 S 16TH PLACE
PHOENIX, AZ 85040
US

Emergency Phone: 800-424-9300 CHEMTREC

Info Phone: 602-243-3293

Preparer: ROBERT COMMISSO

Cage: DO312

GRIGGS PAINT

PHOENIX, AZ 85040-1319 US

Telephone: 602-243-3293

Cage: DO312

XYLENE (SARA 313) (CERCLA) (VAPOR PRESSURE = 5.1MM HG @

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 2%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

.2 MM HG @ 200 F

CAS: 117-81-7

RTECS: TI0350000

Fraction By Weight: 1%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:DIRECT CONTACT W/ EYES MAY CAUSE
IRRITATION. PROLONGED/REPEATED CONTACT MAY CAUSE SKIN IRRITATION.
INHALATION OF HIGH CONCENTRATIONS OF VAPORS MAY LEAD TO LUNG
CHANGES, NAUSEA, VOMITING, COUGH, PULMON ARY IRRITATION, CNS
DEPRESSION. INGEST: ASPIRATION INTO LUNGS MAY CAUSE PNEUMONITIS,
PULMONARY EDEMA, HEMORRHAGE. INGEST:GASTROINTESTINAL DISTURBANCES.
Effects of Overexposure:BREATHING OF HIGH VAPOR CONCENTRATIONS MAY
CAUSE DROWSINESS, DIZZINESS, FATIGUE, FOLLOWED BY COMA. EYE: DIRECT
CONTACT/CONTACT W/ VAPORS MAY CAUSE IRRITAITON. SKIN:
PROLONGED/REPEATED CONTACT MAY CAUS E IRRITATION/DERMATITS. MAY BE
ABSORBED THROUGH SKIN INDICATED BY MODERATE IRRITATION, DEFATTING,
DERMATITS. INGEST: ASPIRATION OF PRODUCT INTO LUNGS MAY CAUSE
PNEUMONITIS, PULMONARY EDEMA, AND HEMORR HAGE. INGESTION MAY CAUSE
GASTROINTESTINAL DISTURBANCES.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/ PRE-EXISTING
DISEASES IN OR HISTORY OF AILMENTS INVOLVING SKIN, CENTRAL NERVOUS
SYSTEM, LIVER AND KIDNEYS.

First Aid:EYES: IMMEDIATELY FLUSH W/LARGE AMOUNTS WATER FOR 15 MINUTES.
SEEK MED AID. SKIN: WASH THOROUGHLY W/SOAP & WATER. SEEK MED AID.
INGEST: IMMEDIATELY SEEK MED AID. DONT INDUCE VOMITING. DONT GIVE
ANYTHI NG BY MOUTH TO UNCONSCIOUS PERSON.

Flash Point Method:TCC
Flash Point:=26.7C, 80.F
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:0.3
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:APPROVED GAS MASK REQUIRED FOR FIRE FIGHTING
PERSONNEL. WATER MAY BE INEFFECTIVE, MAY BE USED TO COOL
CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM IGNITION SOUCES. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
HEAT.

Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCES OF IGNITION. STAY UPWIND. ABSORB WITH INERT MATERIAL. FLUSH
AREA W/WATER. VENTILATE AREA FOR AT LEAST 24 HOURS OR UNTIL AREA
HAS BEEN DECLARED SAFE.

Handling and Storage Precautions:KEEP CONTAINERS CLOSED & UPRIGHT TO
PREVENT LEAKAGE. AVOID FLAMES, WELDING, OPEN LIGHTS, ETC. AVOID
BREATHING VAPORS/SPRAY MISTS. AVOID SKIN/EYE CONTACT. AVOID STORING
MATERIAL NEXT TO/ NEAR OXIDIZING MATERIALS.
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TANKS OR PITS WITHOUT ADEQUATE VENTILATION.

Respiratory Protection:USE MSHA/NIOSH APPROVED UNITS. USE UNITS PER
CURRENT 29 CFR 1910.134 REGULATIONS & FOLLOW MANUFACTURERS'
INSTRUCTIONS & WARNINGS. AIR PURIFYING OV/FILTER UNITS MAY BE
ACCEPTABLE.
Ventilation:LOCAL AND MECHANICAL EXHAUST.
Protective Gloves:RUBBER GLOVES
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS OR GOGGLES
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:MAINTAIN GOOD PERSON HYGIENE. DO NOT USE IN
CONFINED AREAS WITHOUT ADEQUATE VENTILATION.
Supplemental Safety and Health
NK

Boiling Pt:=137.8C, 280.F
Decomp Temp:Decomp Text:NA
Vapor Pres:SEE INGREDIENTS
Vapor Density:>AIR
Spec Gravity:1.1 WATER=1
VOC Pounds/Gallon:570
VOC Grams/Liter:4.76
Viscosity:NA
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTIALLY NIL
Appearance and Odor:VISCOUS LIQUID, W/ STRONG SOLVENT ODOR.
Corrosion Rate:NA

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING, HEAT
Hazardous Decomposition Products:CO & CO2.

Waste Disposal Methods:USE INERT ABSORBENT MATERIAL ON SPILLS. DISPOSE
IN ACCORDANCE WITH ALL FEDERAL, STATE & LOCAL REGULATIONS. THIS
PRODUCT IS A US EPA DEFINED IGNITIBLE HAZ WASTE. DISPOSE OF AS
IGNITIBLE HAZ WASTE IN A CCORDANCE W/ LOCAL/STATE/FED REGULATIONS.
AVOID STORING MATERIAL NEXT TO/ NEAR OXIDIZING MATERIALS. EPA
IGNITIBLE.

SARA Title III Information:XYLENE
State Regulatory Information:WARNING : THIS PRODUCT CONTAINS CHEMICALS
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS, OR
OTHER REPRODUCTIVE HARM.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.