Product ID:MICROSHINE FINE MARINE MICRO GEL POLISH, 5085
MSDS Date:01/01/1999
FSC:NIIN:Submitter:N EN
Status Code:A
MSDS Number: CKLDX

FIBRE GLASS-EVERCOAT CO INC

6600 CORNELL ROAD
CINCINNATI, OH 45242
US

Emergency Phone: 800-424-9300

Info Phone: 513-489-7600

Cage: 18731

FIBRE GLASS-EVERCOAT CO INC

CINCINNATI, OH 45242 US

Telephone: 513-489-7600

Cage: 18731

0.01 MMHG

CAS: 111-46-6

RTECS: ID5950000

CRISTOBALITE; CRYSTALLINE SILICA

CAS: 14464-46-1

RTECS: VV7325000

OSHA PEL see Table Z-3

ACGIH TLV: 0.05 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CONTACT W/LIQUID MAY
RESULT IN IRRITATION, REDNESS, TEARING, AND BLURRED VISION. SKIN:
CONTACT W/WET MATERIAL MAY RESULT IN IRRITATION OF SKIN, POSSIBLE
DERMATITIS, AND POSSIBLE DEFATTING OF SKIN. INHALATION: INHALATION
OF AIRBORNE CRYSTALLINE SILICA GENERATED FROM MECHANICAL BUFFING
MAY CAUSE SILICOSIS AND IS A SUSPECTED CARCINOGEN. SWALLOWING:
INGESTION OF THIS MATERIAL MAY CAUSE GA STROINTESTINAL IRRITATION,
NAUSEA, DIARRHEA, AND VOMITING. ASPIRATION OF MATERIAL INTO THE
LUNGS DUE TO VOMITING MAY PRODUCE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL. CHRONIC: CRYSTALLINE SILICA (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-CRISTOBALITE: IARC
MONO, SUPP. VOL 7, PG 341, 1987: GROUP 1. NTP 8TH ANNUAL RPT ON
CARCINS, 1998: REAS ANTIC TO BE HUMAN CARCIN. IARC HAS CLASSIFIED
CRYSTALLINE SILICA AS GRP 1A C ARCIN (PROBABLY CARCIN TO HUMANS).
CLASSIFICATION IS BASED ON LMTD HUMAN EVID, & SUFFICIENT EVID IN
EXPER ANIMALS. CRYSTALLINE SILICA IS CHEM KNOWN TO (SUPDAT)
Effects of Overexposure:HLTH HAZS: IS CONSIDERED TO BE HAZARDOUS BY
INHALATION, AND IS SUSPECTED HUMAN CARCINOGEN. CRYSTALLINE SILICA
MAY ALSO PRODUCE SILICOSIS WHICH IS A NON-CANCEROUS LUNG DISEASE.
REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED OVEREXPOSURE TO
SOLVENTS WITH NEUROLOGICAL AND OTHER PHYSIOLOGICAL DAMAGE.

First Aid:EYES: FLUSH IMMEDIATELY W/LARGE AMTS OF WATER FOR AT LST 15
MINUTES. SEE PHYSICIAN FOR MEDICAL TREATMENT. SKIN: IMMEDIATELY
WASH AFFECTED AREA W/SOAP & WATER. REMOVE CONTAMINATED CLOTHING.
CONSULT PHY SICIAN IF IRRITATION DEVELOPS. INHAL: REMOVE PERSON TO
FRESH AIR. RESTORE BREATHING. KEEP PERSON WARM AND QUIET. TREAT
SYMPTOMATICALLY. GET MEDICAL ATTENTION. SWALLOWED: KEEP PERSON WARM
AND QUIET. CO NSULT PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.

Flash Point:=116.7C, 242.F
Extinguishing Media:FOAM, CARBON DIOXIDE, AND DRY CHEMICAL. OSHA
FLAMMABILITY CLASS: COMBUSTIBLE LIQUID CLASS IIA.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CONTAINERS TO PREVENT
PRESSURE BUILD-UP WHICH MAY RUPTURE CONTAINERS.
Unusual Fire/Explosion Hazard:NONE KNOWN.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE THE
AREA. WEAR PROTECTIVE EQUIPMENT (SEE SECTION 8-SPECIAL PROTECTION
INFO). AVOID BREATHING VAPORS. CONTAIN SPILL. COLLECT WITH INERT
ABSORBENT AND REMOVE. D ISPOSE OF PROPERLY.

Handling and Storage Precautions:STORE MATERIAL IN A COOL,
WELL-VENTILATED AREA. DO NOT STORE IN ELEVATED TEMPERATURES. DO NOT
USE OR STORE NEAR HEAT, SPARKS, OR OPEN FLAME. KEEP CONTAINERS
TIGHTLY CLOSED. AVOID CONTACT WITH INCOMPAT IBLE MATERIALS
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE
INTERNALLY. AVOID CONTACT WITH EYES AND SKIN. AIRBORNE CRYSTALLINE
SILICA GENERATED DURING MECHANICAL BUFFING MAY CAUSE SILICOSIS AND
IS A POSSIBLE CARCINOGE N.

Respiratory Protection:USE NIOSH APPROVED RESPIRATORS DESIGNED TO
REMOVE PARTICULATE MATTER AND ORGANIC SOLVENT VAPORS.
Ventilation:GEN DILUTION/LOC EXHST VENT SHOULD BE PROVIDED TO KEEP
EXPOSURES BELOW ACCEPTABLE LIMITS (INGRED SECTION) AND TO KEEP
SOLVENT (SUPDAT)
Protective Gloves:GLOVES SHOULD BE MADE OF NEOPRENE/NATURAL RUBBER.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH & DELUGE SHWR MTG ANSI DESIGN CRIT
. PROT GLOVES & PROP CLTHG SHOULD BE WORN TO PVNT SKIN CONT.
BARRIER CREAM MAY BE WORN FOR ADDNL SKIN PROT. IMPERMEABLE CLTHG
SHOULD BE WORN TO (SUPDAT)
Work Hygienic Practices:ALWAYS WASH HANDS AFTER USING THIS MATERIAL,
AND BEFORE EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
EXPLAN OF CARCIN:STATE OF CALIFORNIA OT CAUSE CANCER OR OTHER
REPRODUCTIVE HARM. VENT: VAPORS BELOW THE LOWER EXPLOSION LIMIT.
OTHER PROT EQUIP: PVNT PRLNGD/RPTD CONT OF WET MATL W/SKIN.

Boiling Pt:>100.C, 212.F
B.P. Text:212-482F
Decomp Temp:Decomp Text:NP
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Percent Volatiles by Volume:65-70

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, IGNITION SOURCES, AND
CONTACT WITH INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:FUMES MAY BE PRODUCED WHEN MATERIAL IS
HEATED TO DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE, CARBON
DIOXIDE, AND VARIOUS HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF I/A/W FEDERAL, STATE, & LOCAL REGS.
WASTE FROM THIS PROD MAY BE HAZ AS DEFINED UNDER RCRA 40 CFR 261.
WASTE MUST BE TESTED FOR IGNITABILITY TO DETERM APPLICABLE EPA HAZ
WASTE NUMBERS. BEFOR E ATTEMPTING CLEAN-UP/DISPOSING OF MATL, REFER
TO HAZARD INFO IN OTHER SECTIONS OF THIS SHEET.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.