Product ID:A-A-3164 #37038 BLACK LACQUER
MSDS Date:01/01/1999
FSC:8010
NIIN:00-166-3147
Status Code:A
MSDS Number: CKNQN

GRIGGS PAINT

3602 S 16TH PLACE
PHOENIX, AZ 85040
US

Emergency Phone: 602-243-3293

Info Phone: 602-243-3293

Preparer: ROBERT COMMISSO

Cage: 58963

GRIGGS PAINT

PHOENIX, AZ 85040 US

Telephone: 602-243-3293

Cage: 58963

METHYL AMYL KETONE

CAS: 110-43-0

RTECS: MJ5075000

OSHA PEL 465 MG/M3;100 PPM

ACGIH TLV: 233 MG/M3;50 PPM

MAGNESIUM SILICATE ( TALC )

CAS: 14807-96-6

RTECS: WW2710000

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 2 MG/M3

CYCLOHEXANONE

CAS: 108-94-1

RTECS: GW1050000

OSHA PEL 200 MG/M3;50 PPM

ACGIH TLV: 100 MG/M3;25 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

DIOCTYL PHTHALATE

CAS: 117-81-7

RTECS: TI0350000

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

ACETONE

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 2400 MG/M3;1000 PPM

ACGIH TLV: 1780 MG/M3;750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:ORAL (RAT) IS UNKNOWN.
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:DIRECT CONTACT TO EYES MAY CAUSE
IRRITATION. PROLONGED AND/OR REPEATED CONTACT MAY CAUSES SKIN
IRRITATION. INHALATION OF HIGH CONCENTRACTIONS OF VAPORS MAY LEAD
TO LUNG CHANGES, NAUSEA, VOMITING, COUG H, PULMONARY IRRITATION,
AND CENTRAL NERVOUS SYSTEM DEPRESSION. INGESTION MAY CAUSE
GASTROINTESTINAL DISTURBANCES. ASPIRATION OF THIS PRODUCT INTO THE
LUNGS MAY CAUSE PNEUMONITIS, PULMONARY EDEMA AND HEMORRAGE.
Explanation of Carcinogenicity:NONE SPECIFIED BY MANUFACTURER.
Effects of Overexposure:INHALATION: DROWSINESS, DIZZINESS, FATIGUE,
COMA. EYES: IRRITATION. SKIN CONTACT: IRRITATION, DERMITITIS. SKIN
ABSORPTION: IRRITATION, DEFATING, DERMITITIS. INGESTION:
PNEUMONTITIS, PULMONARY EDEMA, H EMORRAGE, GASTROINTESTINAL
DISTURBANCES.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES IN OR HISTORY OF AILMENTS INVOLVING SKIN, CENTRAL NERVOUS
SYSTEM, LIVER AND KIDNEY.

First Aid:EYE CONTACT: IMMEDIATELY FLUSH WITH LARGE AMOUNT OF WATER FOR
15 MINUTES. SEEK MEDICAL AID. SKIN: WASH THOROUGHLY WITH SOAP AND
WATER. SEEK MEDICAL AID IF IRRITATION PERSISTS. INGESTION:
IMMEDIATELY S EEK MEDICAL AID. DO NOT INDUCE VOMITING. DO NOT
ATTEMPT TO GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.

Flash Point Method:TCC
Flash Point:=-20.C, -4.F
Lower Limits:0.3%
Upper Limits:12.8%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:APPROVED GAS MASK REQUIRED FOR FIRE FIGHTING
PERSONEL. WATER MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL
CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO HEAT.

Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCES OF IGNITION. STAY UPWIND. ABSORB WITH INERT MATERIAL. FLUSH
AREA WITH WATER. VENTILATE AREA FOR AT LEAST 24 HOURS OR UNTIL AREA
HAS BEEN DECLARED SAFE .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CONTAINERS CLOSED AND UPRIGHT TO
PREVENT LEAKAGE. AVOID FLAMES, WELDING, OPEN LIGHTS, ETC. AVOID
BREATHING OF VAPOR AND SPRAY MIST. AVOID SKIN AND EYE CONTACT.
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TANK OR PIT, WITHOUT ADEQUATE VENTILATION.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW TLV (PEL), USE MSHA/NIOSH APPROVED UNITS. USE UNITS
PER CURRENT 29 CFR 1910.134 AND FOLLOW MANUFACTURER'S INSTRUCTIONS
AND WARNINGS. IF WITH IN OSHA PROTECTION FACTOR, AIR PURIFYING
OV/FILTER UNITS OK FOR USE.
Ventilation:LOCAL AND MECHANICAL EXHAUST.
Protective Gloves:RUBBER GLOVES.
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS OR GOGGLES.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS WITHOUT ADEQUATE VENTILATION.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

HCC:F2
Boiling Pt:=55.C, 131.F
B.P. Text:131-724F
Vapor Density:>AIR
Spec Gravity:1.1 (H20=1)
VOC Grams/Liter:2.54
Evaporation Rate & Reference:Solubility in Water:ESSENTIALLY NIL
Appearance and Odor:VISCOUS LIQUID WITH TYPICAL PAINT ODOR.

Stability Indicator/Materials to Avoid:NO
STRONG OXIDIZING AGENT.
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING AND HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL,
STATE, AND LOCAL REGULATIONS.

SARA Title III Information:SEC 313 CHEMICALS SUBJECT TO THE REPORTING
REQUIREMENT: METHYL AMYL KETONE, CYCLOHEXANONE AND DIOCTYL
PHTHALATE.
State Regulatory Information:CALIFORNIA PROP 65: THIS PRODUCT CONTAINS
CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND
BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.