Product ID:PROSEAL #8 ASBESTOS FREE PLASTIC ROOF CEMENT, 034, 7746T71
MSDS Date:09/13/1990
FSC:NIIN:Submitter:N EN
Status Code:A
MSDS Number: CKPXW

GARDNER ASPHALT CORPORATION

TAMPA, FL 33675-5449
US

Emergency Phone: 813-248-2101

Info Phone: 800-237-1155; 800-282-1155 (FL)

Cage: TO688

GARDNER ASPHALT CORPORATION

5449 TAMPA, FL 33675-5449 US

Telephone: 800-237-1155; 800-282-1155 (FL)

Cage: TO688

PETROLEUM ASPHALT

CAS: 8052-42-4

RTECS: CI9900000

ACGIH TLV: 5.0 MG/M3 (FUME)

PETROLEUM SOLVENTS

CAS: 64742-48-9

ACGIH TLV: 100 PPM

CELLULOSIC FIBER

CAS: 9004-34-6

RTECS: FJ5691460

ACGIH TLV: 10 MG/M3 (RESP DUST)

INORGANIC FILLER

ACGIH TLV: 5 MG/M3 (RESP DUST)

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: PETROLEUM SOLVENTS AND
ASPHALT COMPONENTS - CAN CAUSE SEVERE IRRITATION, REDNESS, TEARING
AND BLURRED VISION. SKIN: PETROLEUM SOLVENTS & ASHPHALT COMPONENTS
- PROLONGED OR REPEATED CONTA CT CAN CAUSE MODERATE IRRITATION,
DEFATTING AND DERMATITIS. INHALATION: PETROLEUM SOLVENTS -
EXCESSIVE INHALATION OF VAPORS CAN CAUSE IRRITATION OF NOSE/THROAT,
DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE, POSSIBLE
UNCONCIOUSNESS AND EVEN ASPHYXIATION. INGESTION: ASPIRATION
HAZARD.
Effects of Overexposure:REPORTS HAVE ASSOCIATED REPEATED /PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING PRODUCT MAY BE HARMFUL OR FATAL. REPEATED SKIN CONTACT
HAS BEEN SHOWN TO PRODUCE SKIN TUMORS ON LAB ANIMALS. SIGNS AND
SYMPTOMS SAME AS THOSE STATED IN HEALTH HAZARDS SECTION.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING CENTRAL
NERVOUS SYSTEM DISEASE, SKIN DISORDERS OR CHRONIC RESPIRATORY
DISEASE SHOULD AVOID EXPOSURE TO THIS PRODUCT.

First Aid:EYE CONTACT: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED
CLOTHING, THOROUGHLY WASH EXPOSED AREA WITH SOAP AND WATER. IF
IRRITATION OR R EDNESS DEVELOPS & PERSITS, GET MEDICAL ATTENTION.
INHALATION: REMOVE INDIVIDUAL TO FRESH AIR; IF BREATHING IS
DIFFICULT, ADMINISTER OXYGEN. IF BREATHING HAS STOPPED, GIVE ARTIF
RESPIRATION. KEEP PERS ON WARM & QUIET. GET MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING - TRANSPORT TO HOSPITAL
IMMEDIATELY. GET MEDICAL ATTENTION. NOTE TO PHYSICIAN: PERFORM
GASTRIC LAVAGE IN ACCORDANCE W/ PROCEDU RES FOR INGESTION OF
PETROLEUM PRODUCTS.

Flash Point Method:TCC
Flash Point:=39.4C, 103.F
(PET. SOLVENTS)
Autoignition Temp:>204.4C, 400.F
Lower Limits:0.9%
Upper Limits:6.0%
Extinguishing Media:DRY CHEMICAL & CO*2 OR UNIVERSAL TYPE FOAM/WATER
FOG ARE EFFECTIVE BUT MAY CAUSE FROTHING. DO NOT USE WATER.
Fire Fighting Procedures:FIGHT AS A FUEL OIL FIRE. DECOMPOSITION
PRODUCTS UNDER FIRE CONDITIONS: MAY FORM TOXIC MATERIALS; CARBON
DIOXIDE & CARBON MONOXIDE & NITROGEN OXIDES. FIREFIGHTERS SHOULD
WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:"EMPTY" CONTAINER WARNING: DISPOSE OF IN
ENVIRONMENTALLY SAFE MANNER & IAW GOVERNMENTAL REGS. 'EMPTY'
CONTAINERS RETAIN RESIDUE (LIQUID AND/OR VAPOR) & CAN BE DANGEROUS.
DO NOT PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND OR
EXPOSE SUCH CONTAINERS TO HEAT, FLAME, SPARKS OR OTHER SOURCES OF
(STATE REGULATORY)

Spill Release Procedures:SHUT OFF & ELIMINATE ALL IGNITION SOURCES.
KEEP PEOPLE AWAY. RECOVER FREE PRODUCT. ADD SAND, EARTH OR OTHER
SUITABLE ABSORBENTS TO SPILL AREA. MINIMIZE SKIN CONTACT/BREATHING
OF VAPORS. VENTILATE CONF INED SPACES. OPEN ALL WINDOWS AND DOORS.
KEEP PRODUCT OUT OF SEWERS & WATER COURSES BY DIKING OR IMPOUNDING.
ADVISE AUTHORITIES IF PRODUCT HAS ENTERED OR MAY ENTER SEWERS,
WATER (NEUTRALIZING AGENT)
Neutralizing Agent:SPILL PROC (CONT): COURSES, EXTENSIVE LAND AREAS.
ASSURE CONFORMITY WITH APPLICABLE GOVERNMENTAL REGULATIONS.

Handling and Storage Precautions:HANDLING PRECS: KEEP CONTAINERS
TIGHTLY CLOSED & COOL, DRY & AWAY FROM SOURCES OF IGNITION. USE
PRODUCT W/ADEQUATE VENTILATION. MATL IS COMBUSTIBLE & REQUIRES
ELECTRICAL GROUNDING DURING MATL TRANSFER PROCESS. ALL ELECTRICAL
EQUIP IN STORAGE/HANDLING AREAS SHOULD BE INSTALLED PER NFPA
REQUIREMENTS.
Other Precautions:WORK PRACTICES / ENGINEERING CONTROLS: KEEP
CONTAINERS CLOSED WHEN NOT IN USE. DO NOT STORE NEAR HEAT, SPARKS,
FLAME OR STRONG OXIDANTS. TO PREVENT FIRE OR EXPLOSION RISK FROM
STATIC ACCUMULATION AND DISCHARGE, GROUND PRODUCT TRANSFER SYSTEM
IN ACCORDANCE WITH NFPA STANDARD FOR PETROLEUM PRODUCTS.

Respiratory Protection:A NIOSH APPROVED RESPIRATOR APPROPRIATE FOR THE
EXPOSURE OF CONCERN . USE SUPPLIED AIR RESPIRATORY PROTECTION IN
CONFINED OR ENCLOSED SPACES, IF NEEDED.
Ventilation:SUFFICIENT TO PREVENT EXCEEDING RECOMMENDED EXPOSURE LIMIT
OR BUILDUP OF EXPLOSIVE CONC OF VAPOR IN AIR. USE EXPLOSION-PROOF
EQUIP. NO SMOKING/OPEN LIGHTS.
Protective Gloves:USE CHEMICAL RESISTANT GLOVES TO AVOID PROLONGED OR
REPEATED SKIN CONTACT.
Eye Protection:ANSI APPROVED CHEMICAL SAFETY GOGGLES .
Other Protective Equipment:EYEWASH/DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA . CHEM-RESISTANT APRON/OTHER IMPERVIOUS CLOTHING TO AVOID
CONTAMINATING REGULAR CLOTHING, WHICH COULD RESULT IN
PROLONGED/REPEATED SKIN CONTACT.
Work Hygienic Practices:MINIMIZE BREATHING VAPOR OR MIST. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN. REMOVE CONTAMINATED
CLOTHING; LAUNDER OR DRYCLEAN BEFORE REUSE. REMOVE CONTAMINATED
SHOES (SUPPLEMENTAL SAFETY & HEALTH)
Supplemental Safety and Health
WORK HYGIENIC PRAC (CONT): AND THOROUGHLY CLEAN AND DRY BEFORE REUSE.
CLEANSE SKIN THOROUGHLY AFTER CONTACT BEFORE BREAKS AND MEALS, AND
AT END OF WORK PERIOD. PRODUCT IS READILY REMOVED FROM SKIN BY
WATERLESS HAND CLEANERS FOLLOWED BY WASHING THOROUGHLY WITH SOAP
AND WATER.

Boiling Pt:B.P. Text:300-900F (PETROLEUM SO
Melt/Freeze Pt:M.P/F.P Text:N/A; PROD. IS THICK PASTE
Vapor Pres:6MM HGC 106F-EST.
Vapor Density:3.9; AIR=1
Spec Gravity:GREATER THAN 1.00
Viscosity:>20,000 CPS (THICK PASTE)
Evaporation Rate & Reference:SEE OTHER INFO.
Solubility in Water:INSOLUBLE (@1 ATM & 25C)
Appearance and Odor:VERY THICK CONSISTENCY BLACK PASTE W/SLIGHT
PETROLEUM HYDROCARBON SOLVENT ODOR.
Percent Volatiles by Volume:LESS THAN 25

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDANTS SUCH AS LIQUID CHLORINE,
CONCENTRATED OXYGEN, SODIUM HYPOCHLORITE OR CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:THIS PRODUCT IS STABLE AND WILL NOT REACT
VIOLENTLY WITH WATER.
Conditions to Avoid Polymerization:HAZARDOUS POLYMERIZATION WILL NOT
OCCUR.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH APPLICABLE FEDERAL,
STATE AND LOCAL REGULATIONS .

Toxicological Information:VARIABILITY AMONG INDIVS: HEALTH STUDIES HAVE
SHOWN THAT INDIV SENSITIVITIES VARY. AS A PRECAUTION, EXP TO
VAPORS, LIQUIDS, MISTS, OR FUMES SHOULD BE MINIMIZED. NATURE OF
HAZARD/TOX INFO: PROLONGED/R EPEATED SKIN CONTACT W/PRODUCT TENDS
TO REMOVE SKIN OILS POSS LEADING TO IRRIT & DERMATITIS; HOWEVER,
BASED ON HUMAN EXPERIENCE & AVAIL TOX DATA, PRODUCT IS JUDGED TO BE
NEITHER A 'CORROSIVE' NOR AN ' IRRITANT' BY OSHA CRITERIA. PRODUCT
CONTACTING EYES MAY CAUSE IRRIT. PRODUCT HAS LOW ORDER OF ACUTE
ORAL/DERMAL TOXICITY, BUT MINUTE AMOUNTS ASPIRATED INTO LUNGS
DURING INGESTION MAY CAUSE MILD TO SEV ERE PULMONARY INJURY &
POSSIBLY DEATH.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:TRANSPORTATION INCIDENT INFORMATION: FOR FURTHER
INFO RELATIVE TO SPILLS RESULTING FROM TRANSPORTATION INCIDENTS,
REFER TO LATEST D.O.T. GUIDEBOOK FOR HAZARDOUS MATERIALS INCIDENTS,
D.O.T. P 5800.3. D.O.T. IDENTIFICATION NUMBER: NOT ESTABLISHED.

Federal Regulatory Information:REPORTABLE QUANTITY (RQ), EPA REGULATION
40 CFR 302: NOT ESTABLISHED. THRESHOLD PLANNING QUANTITY (TPQ),
EPA REGULATION 40 CFR 355: NOT ESTABLISHED. TOXIC CHEMICAL RELEASE
REPORTING, EPA REGULATION 40 CFR 372: NOT ESTABLISHED. EPA HAZARD
CLASSIFICATION CODE: NOT APPLICABLE.
State Regulatory Information:UNUSUAL FIRE AND EXPLOSION HAZARD (CONT):
IGNITION, THEY MAY EXPLODE & CAUSE INJURY OR DEATH. DO NOT ATTEMPT
TO CLEAN SINCE RESIDUE IS DIFFICULT TO REMOVE. FOR WORK ON TANKS,
REFER TO OSHA REGULATION ANSI Z49.1 & OTHER GOVERNMENTAL &
INDUSTRIAL REFERENCES PERTAINING TO CLEANING, REPAIRING, WELDING OR
OTHER CONTEMPLATED OPERATIONS.