Product ID:MIL-C-22750F #17178 TYI F-09P373
MSDS Date:01/31/1995
FSC:NIIN:Submitter:N EN
Status Code:A
MSDS Number: CKWSC

SHERWIN-WILLIAMS, SEAGUARD

3560 ELM AVENUE
PORTSMOUTH, VA 23704
US

Emergency Phone: 757-397-2223

Info Phone: 757-397-2223

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

MIXTURE)

ACGIH TLV: 10 MG/M3

METHYL ETHYL KETONE

CAS: 78-93-3

RTECS: EL6475000

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

EPOXY RESIN

CAS: 25085-99-8

ACGIH TLV: NO INFO

AROMATIC 150

CAS: 64742-94-5

RTECS: WF3100000

ACGIH TLV: 10 PPM

SILICON DIOXIDE

CAS: 14808-60-7

RTECS: VV7330000

ACGIH TLV: 0.1 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EFFECTS OF OVEREXPOSURE: CANCER
HAZARD. CONTAINS SILICA WHICH CAN CAUSE CANCER (RISK DEPENDS ON
DURATION & LEVEL OF EXPOSURE). BREATHING OF HIGH VAPOR
CONCENTRATIONS MAY PRODUCE NARCOSIS. LIQUID MAY C AUSE MINOR SKIN
IRRITATION AND DEFINITE EYE IRRITATION. CAUSES NOSE & THROAT
IRRITATION. CAUSES EYE IRRIT. CAUSES SKIN IRRIT. REPEATED &
PROLONGED EXPOSURE TO SOLVENTS COULD CAUSE PERMANENT BRAIN & NE
RVOUS SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & INHALING CONTENTS MAY BE HARMFUL OR FATAL.
Explanation of Carcinogenicity:KNOWN OR SUSPECTED CARCINOGEN: SILICON
DIOXIDE. SILICON DIOXIDE (CRYSTALINE SILICA, QUARTZ): IARC GROUP
1, VOL 68, PAGE 41, 1997. KNOWN HUMAN CARCINOGEN, NTP NINTH ANNUAL
REPORT ON CARCINOGENS, 199 8.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT
PHYSICIAN. SKIN: FLUSH WITH WATER. EYE CONTACT: FLUSH IMMEDIATELY
WITH LARGE AMOUNTS OF WATER. CONSULT PHYSICIAN. FIRST AID: IN CASE
OF EY E CONTACT, FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR AT
LEAST 15 MINUTES AND GET IMMEDIATE MEDICAL ATTENTION; FOR SKIN,
WASH THOROUGHLY WITH SOAP AND WATER. IF SWALLOWED, GET MEDICAL
ATTENTION IMMEDI ATELY.

Flash Point Method:SCC
Flash Point:=-4.4C, 24.F
Lower Limits:1.0%
Upper Limits:17.8%
Extinguishing Media:DRY CHEMICAL, WATER FOG, CARBON DIOXIDE, FOAM,
ALCOHOL (FOAM).
Fire Fighting Procedures:FULL EMERGENCY EQUIPMENT WITH SELF-CONTAINED
BREATHING APPARATUS (NIOSH APPROVED - ) AND FULL PROTECTIVE
CLOTHING SHOULD BE WORN BY FIRE FIGHTERS. WHEN FIGHTING A FIRE
INVOLVING ALUMINUM PASTE DO NOT USE A WATER HOSESTREAM. DO NOT USE
HALOGENATED EXTINGUISHING AGENTS. ALUMINUM FIRE (SUPPLEMENTAL
SAFETY AND HEALTH)
Unusual Fire/Explosion Hazard:FLAMMABILITY CLASSIFICATION:
OSHA-FLAMMABLE LIQUID CLASS III; D.O.T.-FLAMMABLE LIQUID OR SOLID.
KEEP CONTAINERS TIGHTLY CLOSED. VAPORS MAY MIGRATE TO IGNITION
SOURCE & CAUSE FLASH FIRE. ISOLATE FROM H EAT, SPARKS, ELECTRICAL
EQUIPMENT, APPLIANCES, PILOT LIGHTS, FLAMES, OTHER SOURCES OF
IGNITION. FLAMMABLE LIQUID/VAPOR.

Spill Release Procedures:IN CASE OF SPILLAGE ABSORB WITH INERT MATERIAL
AND DISPOSE OF IN ACCORDANCE WITH APPLICABLE REGULATIONS OF EPA AND
OTHER LOCAL, STATE AND FEDERAL AUTHORITIES.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, OPEN
FLAME. GROUND CONTAINERS DURING STORAGE AND TRANSFER OPERATIONS.
STORE IN TIGHTLY CLOSED CONTAINERS TO PREVENT MOISTURE
CONTAMINATION. STORE AWAY FROM HEAT, SPARKS, O PEN FLAME. AVOID
PROLONGED SKIN CONTACT. DO NOT BREATHE SPRAY MIST. STORE IN A
(OTHER PRECAUTIONS)
Other Precautions:GROUND CONTAINERS WHILE POURING. AVOID SPONTANEOUS
COMBUSTION OF CONTAMINATED RAGS OR OTHER ORGANIC MATERIALS. EMPTY
CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES AND CAN BE DANGEROUS.
HANDLING & S TORAGE PRECAUTIONS (CONT): COOL DRY AREA WITH
VENTILATION SUITABLE FOR STORING MATERIALS SHOWN IN (I NGREDIENTS)
SECTION.

Respiratory Protection:NIOSH/OSHA APPROVED RESPIRATOR TYPES SUITABLE
FOR MATERIALS LISTED IN INGREDIENTS SECTION. APPROVED
CHEMICAL/MECHANICAL FILTERS RECOMMENDED WHEN VENTILATION IS
RESTRICTED. WEAR APPROPRIATE RESPIRATOR DURING & AFTER APPLICATION
UNLESS AIR MONITORING RECORDS VAPOR/MIST BELOW APPLICABLE LIMITS.
FOLLOW RESPIRATOR MANUFACTURER DIRECTIONS FOR USE.
Ventilation:SUFFICIENT VENT. (IN VOLUME/PATTERN) SHOULD BE PROVIDED TO
KEEP AIR CONTAMINATION BELOW CURRENT APPLICABLE OSHA PERMISSIBLE
EXPOSURE LIMIT OR ACGIH'S TLV LIMIT.
Protective Gloves:CHEMICAL-RESISTANT GLOVES.
Eye Protection:ANSI-APPROVED CHEMICAL SAFETY GOGGLES .
Other Protective Equipment:AS REQUIRED TO AVOID WETTING CLOTHING. COVER
AS MUCH OF SKIN AREA AS POSSIBLE WITH APPROPRIATE CLOTHING.
RECOMMENDED FOR PROLONGED OR REPEATED CONTACT: CHEMICAL RESISTANT
PLASTIC OR RUBBER.
Work Hygienic Practices:AVOID CONTACT WITH EYES, SKIN & CLOTHING. WASH
THOROUGHLY AFTER HANDLING. USE PROTECTIVE CREAMS WHERE CONTACT WITH
SKIN IS LIKELY. REMOVE & WASH CONTAM CLOTHING BEFORE REUSE. EYE
BATH & SAFETY SHOWER.
Supplemental Safety and Health
DO NOT BREATHE DUST, VAPORS OR SPRAY MIST. FIRE FIGHTING PROCEDURE
(CONT): MAY REACT WITH WATER TO FORM HYDROGEN GAS WHICH IS
FLAMMABLE. USE NIOSH APPROVED GAS MASK FOR FIRE FIGHTING PERSONNEL.
WA TER MAY BE USED TO COOL CONTAINERS. IF WATER IS USED FOG NOZZLES
ARE PREFERRED.

Boiling Pt:=79.4C, 175.F
B.P. Text:RANGE 175-401F
Vapor Pres:SEE OTHER INFO
Vapor Density:> AIR
Spec Gravity:DENSITY: 11.0 LB/GAL
VOC Pounds/Gallon:365
VOC Grams/Liter:3.04
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:INSOLUBLE.
Appearance and Odor:LIQUID; SOLVENT ODOR.
Percent Volatiles by Volume:39.4%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS. ALUMINUM CAN REACT VIOLENTLY WITH HALOGENATED
HYDROCARBONS INCLUDING HALOGENATED FIRE EXTINGUISHING AGENST.
ALUMINUM WILL REACT WITH WATER TO SLOWLY GENERATE HYDROGEN AND
HEAT. THIS REACTION (HAZAR
Stability Condition to Avoid:THIS PRODUCT IS STABLE UNDER NORMAL
STORAGE CONDITIONS. CONDITIONS TO AVOID: EXCESSIVE HEAT, SPARKS,
OPEN FLAME.
Hazardous Decomposition Products:N/P. MATERIALS TO AVOID (CONT):
CAN BE ESPECIALLY HAZARDOUS IN CONFINED SPACES LIKE A SEALED DRUM
DUE TO BUILD-UP OF PRESSURE.
Conditions to Avoid Polymerization:WILL NOT OCCUR UNDER NORMAL
CONDITIONS.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, COUNTY, STATE AND FEDERAL REGULATIONS.

Toxicological Information:N/P.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

SARA Title III Information:THIS PRODUCT CONTAINS ONE OR MORE MATERIALS
SUBJECT TO REPORTING REQUIREMENTS OF SECTION 313: METHYL ETHYL
KETONE.