Product ID:X-5700-R MIAMI BLUE RANDACRYL
MSDS Date:11/13/1992
FSC:NIIN:Submitter:F BT
Status Code:A
MSDS Number: CKXQQ

RANDOLPH PRODUCTS CO

701 12TH ST
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 201-438-3700

Info Phone: 201-438-3700

Preparer: JHR

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

SUCROSE ACETATE ISOBUTYRATE

ACGIH TLV: 1000 PPM

ACRYLIC RESIN SOLUTION

ACGIH TLV: 100 PPM

METHYL ETHYL KETONE

CAS: 78-93-3

RTECS: EL6475000

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYLENE GLYCOL MONOMETHYL ETHER ACETATE

CAS: 108-65-6

RTECS: AI8925000

ACGIH TLV: 100 PPM

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Effects of Overexposure:CHRONIC HEALTH EFFECTS ARE POSSIBLE FROM LONG
TERM EXPOSURE TO THIS MATERIAL, INCLUDING DRYING, CRACKING AND
IRRITATION OF THIS SKIN. REACTS WITH SKIN PROTEIN AND MOISTURE AND
CAN CAUSE RASH, SCALING OR BLISTERING. HIGH CONCENTRATIONS MAY
CAUSE HEADACHES AND DIZZINESS, ARE ANESTHETIC, AND MAY HAVE OTHER
CENTRAL NERVOUS SYSTEM EFFECTS, INCLUDING DEATH.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS CAN CAUSE A HEIGHTENED REACTION TO EXPOSURE TO THIS
PRODUCT. CONTACT LENS WEARERS SHOULD CONSULT PROVIDER BEFORE
HANDLING.

First Aid:INHALATION: REMOVE TO FRESH AIR, RESTORE BREATHING. SKIN:
FLUSH WITH WATER. EYE: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF
WATER. IN ALL CASES, SEEK IMMEDIATE MEDICAL ATTENTION!

Flash Point Method:SCC
Flash Point:=-8.3C, 17.F
Lower Limits:1.2
Upper Limits:11.4
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WATER STREAM WILL SPREAD FIRE. DO NOT USE
WATER HOSE STREAM. FULL BUNKER GEAR IN FIRE AREA. VAPORS>AIR MAY
TRAVEL TO DISTANT IGNITION SOURCES & FLASHBACK.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT,SPARKS,AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUI LD-UP AND POSSIBLE AUTOIGNITION
OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT. REMOVE ALL NON-ESSENTIAL
PERSONNEL FROM FIRE

Spill Release Procedures:AVOID BREATHING SOLVENT VAPOR. ENSURE ADEQUATE
VENTILATION. AVOID SPARKS, FLAMES, AND ANYTHING WHICH COULD CAUSE
FIRE. ELIMINATE SOURCE OF SPILL IF YOU CAN DO SO WITHOUT RISK BY
CLOSING VALVE, PLUGGIN G HOLE, ETC.. APPLY ABSORBENT INERT MATERIAL
(SAND, DUST, VERMICULITE) TO SPILL. CLEAN SPILL WITH BRISTLE
BROOMS, NON-SPARKING TOOLS, CLEAN DRY RAGS. PROTECTIVE CLOTHING
SHOULD BE WORN.

Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED WHEN BEING
EMPTIED.
Other Precautions:PROVIDE RESPIRATORY PROTECTION AGAINST FUMES
GENERATED DURING BURNING.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR TYPES SUITABLE
FOR MATERIALS RECOMMENDED. APPROVED CHEMICAL/MECHANICAL FILTERS
RECOMMENDED WHEN VENTILATION IS RESTRICTED. PRECAUTIONS MUST BE
TAKEN SO THAT PERSONS DO N OT BREATHE THE VAPORS OR HAVE CONTACT
WITH EYES OR SKIN. PROTECT AGAINST EXPOSURE TO BOTH VAPOR AND SPRAY
MIST.
Ventilation:SUFFICIENT VENTILATION, IN VOLUME AND PATTERN, SHOULD BE
PROVIDED TO KEEP AIR CONTAMINATION BELOW EXPOSURE LIMITS.
Protective Gloves:WEAR PROTECTIVE GLOVES.
Eye Protection:CHEMICAL GOGGLES WITH SIDE SHIELDS OR FACE SHIELD
RECOMMENDED.
Other Protective Equipment:USE PROTECTIVE CREAMS WHERE SKIN CONTACT IS
LIKELY.
Work Hygienic Practices:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE
REUSE. USE NORMAL HYGIENE PRACTICES DURING AND AFTER HANDLING THIS
MATERIAL.
Supplemental Safety and Health
WT/GAL = 8.2 HMIS RATING: HEALTH=1, FLAMMABILITY=3, REACTIVITY=0.

Boiling Pt:B.P. Text:105-302 F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:THIN BLUE LIQUID WITH A TYPICAL SOLVENT ODOR.
Percent Volatiles by Volume:69.9

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:AVOID STRONG OXIDIZERS, ACIDS AND
ALKALIES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION RELEASES CARBON
MONOXIDE AND/OR CARBON DIOXIDE.

Waste Disposal Methods:SOAK LIQUIDS WITH SAWDUST OR RAGS AND REMOVE.
FLUSH WITH WATER IF POSSIBLE. AVOID SKIN CONTACT. DISPOSAL SHOULD
BE IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. DO
NOT INCINERATE, CUT OR WELD EMPTY CONTAINERS. WHEN DISCARDED THIS
MATERIAL IS A HAZARDOUS WASTE. TRANSFER LIQUID TO CO NTAINERS FOR
RECOVERY OR DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

SARA Title III Information:THIS PRODUCT CONTAINS ONE OR MORE MATERIALS
SUBJECT TO THE REPORTING REQUIREMENTS.
Federal Regulatory Information:EPA HAZARDOUS WASTE CODE F003. HAZARDOUS
WASTE CHARACTERISTIC ? IGNITABILITY.