Product ID:INTERLAC 1 HAZE GRAY 45587A
MSDS Date:01/31/2000
FSC:8010
NIIN:01-441-6151
Status Code:A
MSDS Number: CKXRF

COURTAULDS COATINGS INC. INTERNATIONAL

6001 ANTOINE DRIVE
HOUSTON, TX 77091
US

Emergency Phone: (800)424-9300

Info Phone: 713-684-1563

Preparer: HENRY SIMMONS

Cage: 028S6

INTERNATIONAL PAINT INC

HOUSTON, TX 77091 US

Telephone: 713-684-1244

Cage: 028S6

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

TRIMETHYLBENZENE

CAS: 25551-13-7

RTECS: DC3220000

ACGIH TLV: 123 MG/M3;25 PPM

1,2,4-TRIMETHYLBENZENE

CAS: 95-63-6

RTECS: DC3325000

MAGNESIUM SILICATE HYDRATE

CAS: 1343-90-4

RTECS: OM4360000

N-BUTYL ALCOHOL

CAS: 71-36-3

RTECS: EO1400000

OSHA PEL 300 MG/M3;100 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

AMORPHOUS SILICA FUME

CAS: 69012-64-2

RTECS: VV7312000

ACGIH TLV: 2 MG/M3

AROMATIC HYDROCARBONS

CAS: 63231-51-6

FERRIC OXIDE

CAS: 1309-37-1

RTECS: NO7400000

OSHA PEL 10 MG/M3

ACGIH TLV: 5 MG/M3;2 PPM

ETHYLBENZOL

CAS: 100-41-4

RTECS: DA0700000

OSHA PEL 435 MG/M3;100 PPM

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SILICA GEL, PPTD., CRYST.-FREE

CAS: 112926-00-8

RTECS: VV7315000

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 10 MG/M3

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Effects of Overexposure:INHALATION: VAPOR HARMFUL. MAY AFFECT THE BRAIN
OR NERVOUS SYSTEM CAUSING DIZZINESS, HEADACHE OR NAUSEA. MILDLY
TOXIC BY INHALATION. CAUSES NOSE AND THROAT IRRITATION. EYE
CONTACT: CAUSES EYE IRRITATI ON. SKIN CONTACT: MAY BE HARMFUL IF
ABSORBED THROUGH THE SKIN. CAUSES SKIN IRRITATION. INGESTION: MAY
BE FATAL IF SWALLOWED.

First Aid:GENERAL: IN ALL CASES OF DOUBT, OR WHEN SYMPTOMS PERSIST,
SEEK MEDICAL ATTENTION. NEVER GIVE ANYTHING TO AN UNCONSCIOUS
PERSON. INHALATION: REMOVE TO FRESH AIR. IF DISCOMFORT IS PRESENT
OR BREATHING I S ABSENT GET MEDICAL ATTENTION IMMEDIATELY. EYE
CONTACT: FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR 15 MINUTES
UNTIL IRRITATION SUBSIDES. IF IRRITATION PERSITS, GET MEDICAL
ATTENTION. SKIN CONTACT: FL USH WITH LARGE AMOUNTS OF WATER. USE
SOAP IF AVAILABLE. REMOVE SEVERELY CONTAMINATED CLOTHING (INCLUDING
SHOES) AND WASH BEFORE REUSE. IF IRRITATION PERSITS, GET MEDICAL
ATTENTION. INGESTION: IF SWALL OWED, DO NOT INDUCE VOMITING.

Flash Point:=40.C, 104.F
Lower Limits:.5
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, SPARKS, ELETRICAL
EQUIPMENT AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. IN THE ABSENCE OF ELECTRICITY, A WATER
SPRAY (A FOG NOZZLE IS PREFERRED) MA Y BE USED TO COOL CONTAINERS.
DECOMPOSITION AND COMBUSTION PRODUCT MAY BE TOXIC.

Spill Release Procedures:CONTAIN SPILLED LIQUID WITH SEND OR EARTH. DO
NOT USE COMBUSTIBLE MATERIALS SUCH AS SAWDUST. ABSORB SPILL WITH AN
INERT MATERIAL (E.G, DRY SAND OR EARTH), THEN PLACE IN A CHEMICAL
WASTE CONTAINER.

Handling and Storage Precautions:KEEP CONTAINER CLOSED, LOOSEN CLOSURE
CAUTIOUSLY BEFORE OPENING. STORE IN A COOL, WELL VENTIALATED PLACE
AWAY FROM INCOMPATIBLE MATERIALS. KEEP AWAY FROM HEAT, SPARKS AND
FLAMES. PROTECT MATERIAL FROM DIRECT SUNLIGHT. GROUND AND BOUND
CONTAINERS WHEN TRANSFERRING MATERIALS.

Respiratory Protection:DO NOT BREATHE VAPORS OR SPRAY MISTS. IF YOU
EXPERIENCE EYE WATERING, HEADACHE OR DIZZINESS OR IF AIR MONITORING
DEMOSTRATES VAPOR/MIST LEVELS ARE ABOVE APPLICABLE LIMITS, WEAR AN
APPROPRIATE PROPERLY RESPIRATOR (NIOSH APPROVED) DURING AND AFTER
APPLIACTION. FOLLOW RESPIRATOR MANUFACTURER'S DIRECTIONS FOR
RESPIRATOR USE.
Ventilation:KEEP THE TLV OF THE HAZARDOUS INGREDIENTS BELOW THE LIMITS
SPECIFIED IN SECTION TWO. REMOVE VIOLATES PRODUCED DURING CURE AND
DECOMPOSITION PRODUCTS.
Protective Gloves:WEAR CHEMICAL RESISTANT GLOVES.
Eye Protection:SAFETY GLASSES, CHEMICAL GOGGLES AND/OR A FACE SHIELD
SHOULD BE WORN .
Other Protective Equipment:WEAR CHEMICAL RESISTENT GLOVES.
Supplemental Safety and Health

Boiling Pt:=63.9C, 147.F
Vapor Density:> AIR
Spec Gravity:1.38
Evaporation Rate & Reference:SLOER/ETHER
Appearance and Odor:LIQUID

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO A DECOMPOSITION SI IN WELDING. FUMES MAY PRODUCE CARBON
DIOXIDE AND CARBON MONOXIDE.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATIONS. DO NOT INCINERATE UNOPENED CONTAINERS.

Toxicological Information:THERE IS NO DATA AVAILABLE ON THE PRODUCT
ITSELF. CONTAINS 1,2,4-TRIMETHYL BENZENE WHICH CAN CAUSE CENTRAL
SYSTEM DEPRESSION, ANEMIA AND BRONCHITIS. NOTICE: REPORTS HAVE
ASSOCIATED REPEATED AND PROLON GED OCCUPATIONAL OVEREXPOSURE TO
SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. ITENTIONAL
MIUSE BY DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY
BE HARMFUL OR FATAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:THERE IS NO DATA AVAILABLE ON THE PRODUCT ITSELF.

Transport Information:DOT (DEPARTMENT OF TRANSPORATION) PROPER SHIPPING
NAME: PAINT HAZARD CLASS: FLAMMABLE LIQUID, 3 UN NUMBER: UN1263
PACKING GROUP: PACKING GROUP III

SARA Title III Information:NONE KNOWN UNLESS CHEMICALS ARE SPECIFIED
BELOW. SECTION 302 REPORTABLE INGREDIENTS 313 REPORTABLE
INGREDIENTS 000071-36-3 N-BUTYL ALCOHOL 000095-63-6
1,2,4-TRIMETHYLBENZENE 000100-41- 4 ETHYBENZENE
001330-20-7 XYLENE.
Federal Regulatory Information:TSCA (TOXIC SUBSANCE CONTROL ACT)
COMPONENTS OF THIS PRODUCTS ARE LISTED ON THE TSCA INVENTORY. CERLA
(COMPREHENSION RESPONSE COMPENSATION, AND LIABILITY ACT): WE
RECOMMEND YOU CONTACT LOCAL AUTHORITE S TO DETERMINE IF THESE MAY
BE OTHER LOCAL REPORTING REQUIREMENTS.
State Regulatory Information:CALIFORNIA PROPOSITION 65: NONE KNOWN
UNLESS SPECIFED BELOW. WARNING: THIS PROUCT CONTAINS A CHEMICAL
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM. WARNING: THIS PRODUCT CONTAINS A CHEMICAL
KNOWN TO THE STATE OF CALLIFORNIA TO CAUSE CANCER.