CKYNY - LACQUER
- MSDS: CKYNY
- Manufacturer: GEMINI COATINGS INC
- Product Name: LACQUER
- National Stock Number: 8010-00-527-2624
Product Identification
Product ID:LACQUER
MSDS Date:07/27/2000
FSC:8010
NIIN:00-527-2624
Status Code:A
MSDS Number: CKYNY
Responsible Party
EL RENO, OK 73036
US
Emergency Phone: (800)424-9300
Info Phone: 405-262-5710
Preparer: HENRY SIMMONS
Cage: 073P7
Contractor
Telephone: 405-262-5710
Cage: 073P7
Ingredients
PHTHALATE ESTER 37
MALEIC RESIN
NITROCELLULOSE
CAS: 9004-70-0
RTECS: QW0970000
ISOBUTYL ACETATE
CAS: 110-19-0
RTECS: AI4025000
OSHA PEL 700 MG/M3;150 PPM
ACGIH TLV: 713 MG/M3;150 PPM
EPA Report Quantity: 5000 LBS
DOT Report Quantity: 5000 LBS
METHYL ETHYL KETONE
CAS: 78-93-3
RTECS: EL6475000
OSHA PEL 590 MG/M3;200 PPM
ACGIH TLV: 590 MG/M3;200 PPM
EPA Report Quantity: 5000 LBS
DOT Report Quantity: 5000 LBS
ISOBUTYL ISOBUTYRATE
CAS: 97-85-8
RTECS: NQ5250000
TOLUENE
CAS: 108-88-3
RTECS: XS5250000
OSHA PEL see Table Z-2
ACGIH TLV: 188 MG/M3;50 PPM
EPA Report Quantity: 1000 LBS
DOT Report Quantity: 1000 LBS
METHANOL
CAS: 67-56-1
RTECS: PC1400000
OSHA PEL 260 MG/M3;200 PPM
ACGIH TLV: 262 MG/M3;200 PPM
EPA Report Quantity: 5000 LBS
DOT Report Quantity: 5000 LBS
First Aid
First Aid:EYE CONTACT: FLUSH WITH LUKE WARM WATER FOR 15 MINUTES. SEEK
PHYSICIAN IMMEDIATELY SKIN CONTACT: REMOVE CONTAMINATED CLOTHING,
WASH AREA IMMEDIATELY WITH SOAP AND WATER. SEE PHYSICIAN IF
IRRITATION P ERSISTS. INHALATION: REMOVED EXPOSED INDIVIDUAL TO
FRESH AIR AND AID BREATHING IF NECESSARY. CONTACT PHYSICIAN
IMMEDIATELY. INGESTION: RINSE MOUTH IMMEDIATELY. DRINK 1 OR 2
GLASSES OF WATER TO DILUT E. DO NOT INDUCE VOMITING. CONTACT
PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
Fire Fighting
Flash Point Method:TCC
Flash Point:=-3.7C, 25.F
Lower Limits:1
Upper Limits:36
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL. THE NATIONAL FIRE
PROTECTION ASSOCIATION CLASS B EXTINGUISHER IS DESIGNED TO
EXTINGUISH NFPA CLASS 1B FLAMMABLE LIQUID FIRES.
Fire Fighting Procedures:CLEAR FIRE AREA OF UNPROTECTED PERSONNEL. DO
NOT ENTER CONFINED SPACE WITHOUT HELMET, FACE SHIELD, BUNKER COAT,
GLOVES, RUBBER BOOTS, AND A POSITIVE PRESSURE NIOSH- APPROVED
SELF-CONTAINED BREATHING A PPARATUS. A WATER STREAM CAN SCATTER
FLAMES. A SPRAY OF WATER MAY BE USED TO COOL CLOSED CONTAINERS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. DO NOT APPLY
TO HOT SURFACES. NEVER USE WELD ING OR CUTTING TORCH ON OR NEAR
CONTAINER (EVEN EMPTY) BECAUSE PRODUCT (EVEN RESIDUE) MAY IGNITE
EXPLOSIVELY.
Accidental Release
Spill Release Procedures:STAY UPWIND AND WAY FROM SPILL OR LEAK UNLESS
WEARING APPROPRIATE PROTECTIVE EQUIPMENT. STOP AND/OR CONTAIN
DISCHARGE IF IT MAY BE DONE SAFELY. KEEP ALL SOURCES OF IGNITION
AWAY. VENTILATE AREA OF SPI LL. USE NON-SPARKING TOOLS FOR CLEAN
UP. COVER WITH INERT MATERIAL TO REDUCE FUMES. KEEP OUT OF DRAINS,
SEWER, OR WATERWAYS. IF LARGE SPILL OCCURS, ALERT SPILL RESPONSE
TEAMS.
Handling
Handling and Storage Precautions:KEEP PRODUCT CONTAINERS COOL, DRY, AND
AWAY FROM SOURCES OF IGNITIONS. USE AND STORE THIS PRODUCT WITH
ADEQUATE VENTILATION. DO NOT SMOKE IN STORAGE AREAS. BOND AND
GROUND METAL CONTAINERS WHEN TRANS FERRING LIQUID. AVOID FREE FALL
OF LIQUID IN EXCESS OF A FEW INCHES.
Exposure Controls
Ventilation:USE LOCAL EXHAUST AS REQUIRED TO CONTROL VAPOR
CONCENTRATIONS. AVOID PROLONGED OR REPEATED BREATHING OF VAPORS.
Protective Gloves:WEAR RESISTANT-GLOVES SUCH AS NATURAL RUBBER,
NEOPRENE, BUNAN OR NITRILE.
Eye Protection:WEAR SPLASHPROOF GOGGLES OR FACE SHIELD .
Work Hygienic Practices:WASH HANDS THOROUGHLY BEFORE EATING OR USING
THE RESTROOM. REMOVE CONTAMINATED CLOTHING AND DO NOT WEAR AGAIN
UNTIL IT HAS BEEN PROPERLY LAUNDERED.
Supplemental Safety and Health
Chemical Properties
Boiling Pt:=64.4C, 148.F
B.P. Text:148-298F
Vapor Pres:138MMGH@68F
Vapor Density:>AIR
VOC Pounds/Gallon:649
VOC Grams/Liter:7.71
Evaporation Rate & Reference:FASTER THAN BUTYL ACETENE
Appearance and Odor:LIQUID
Percent Volatiles by Volume:75.67
Stability
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ALKALINES, STRONG MINERAL ACIDS.
Stability Condition to Avoid:HIGH HEAT, SPARKS, FLAMES.
Hazardous Decomposition Products:OXIDATION MAY PRODUCE CARBON AND
NITROGEN OXIDES.
Conditions to Avoid Polymerization:WILL NOT OCCUR
Disposal
Waste Disposal Methods:DO NOT FLUSH TO SEWER, WATERSHED, OR WATERWAY.
DISPOSE OF PRODUCT IN ACCORDANCE WITH APPLICABLE LOCAL, COUNTY,
STATE, AND FEDERAL REGULATIONS.
Toxicology
Toxicological Information:WIDESPREAD CONTACT WITH SKIN FOR SEVERAL
HOURS CAN CAUSE HARMFUL AMOUNTS OF MATERIAL TO BE ABSORBED.
EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL AND RESPIRATORY
IRRITATION, DIZZINESS, WEAKNESS, FA TIGUE, NAUSEA, HEADACHE,
POSSIBLE UNCONSCIOUSNESS AND EVEN ASPHYXIATION. HIGH VAPOR
CONCENTRATIONS OR PROLONGED BREATHING OF LOWER CONCENTRATIONS MAY
RESULT IN DAMAGE TO THE LIVER, KIDNEYS, LUNGS AND BLOOD FORMING
ORGANS.
Other Information
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
Ecology
Ecological:UNCONTROLLED RELEASES OF THIS PRODUCT MAY CONTAMINATE AIR,
GROUND, WATERWAYS, AND OR SEWERS.
Regulatory
SARA Title III Information:THIS M.S.D.S. IS COMPLIANCE WITH SECTION 313
OF SARA III
Federal Regulatory Information:THIS PRODUCT CONTAINS THE FOLLOWING
TOXIC CHEMICALS TO THE REPORTING REQUIREMENTS OF SECTION 313 OF THE
EMERGENCY PLANNING AND COMMUNITY RIGHT TO KNOW ACT OF 1986 AND OF
40 CFR 32: METHYL ETHYL KETONE CAS# 78-93-3 PCT BY WT: 4.4260
TOULENE CAS# 108-88-3 PCT BY WT: 49.3810 METHANOL CAS# 67-56-1 PCT
BY WT 4.6490
State Regulatory Information: