Product ID:ULTRAGLO 8800 A AEROSOL SPRAY
MSDS Date:07/27/1994
FSC:6850
NIIN:01-445-2421
Status Code:A
MSDS Number: CLBRJ

Emergency Phone: 714-739-2821

Info Phone: 714-739-2821

Preparer: STEPHEN MORRIS

Cage: 23373

Telephone: 714-739-2821

Cage: 23373

HYDROTREATED MIDDLE DISTILLATE

CAS: 64742-46-7

RTECS: JN9379645

OSHA PEL 5 MG/M3 MIST

ACGIH TLV: 5 MG/M3 MIST

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT HAS A LOW VAPOR PRESSURE
AND IS NOT EXPECTED TO PRESENT AN INHALATION HAZARD AT AMBIENT
CONDITIONS. IF MISTED, AND CONCENTRATIONS ARE KEPT BELOW TLV,
PRODUCT IS WITHOUT SIGNIFICANT HEALT H RISK. ACUTE OVEREXPOSURE
MAY RESULT IN IRRITATION OF THE THROAT AND LUNGS. CHRONIC EXPOSURE
TO HIGH CONCENTRATIONS OF AEROSOLS OR MISTS TO LABORATORY ANIMALS
HAS RESULTED IN NON-SPECIFIC SYMPTOMS RELATED TO THE NERVOUS
SYSTEM, GASTROINTESTINAL TRACT, AND LUNGS. AVOID SKIN & EYE
CONTACT. DO NOT INGEST.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN CHEMICALS
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER OR REPRODUCTIVE
TOXICITY.
Effects of Overexposure:THIS PRODUCT MAY CAUSE MODERATE SKIN IRRITATION
UPON DIRECT CONTACT. SINGLE CONTACT MAY CAUSE DERMATITIS WHICH IS
CHARACTERIZED BY DRYNESS, CHAPPING, AND REDDENING. THIS CONDITION
MAY MAKE THE SKIN MORE SUSCEPTIBLE TO OTHER IRRITANTS,
SENSITIZERS, AND DISEASE. EXPOSURE TO HIGH CONCENTRATIONS OF
VAPORS MAY BE IRRITATING TO THE EYES. SEVERE ORAL INTOXICATION
WILL LEAD TO INTENSE BURNING OF THE T HROAT AND MAY RESULT IN
DROWSINESS, WEAKNESS, AND NAUSEA, LOSS OF CONSCIOUSNESS AND
CONVULSIONS FOLLOWED BY DEATH. ASPIRATION MAY LEAD TO CHEMICAL
PNEUMONITIS WHICH IS CHARACTERIZED BY PULMONARY EDEM A AND
HEMORRAGE.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
CONDITIONS MAY BE SUSCEPTIBLE TO THE EFFECTS OF A COMPONENT OF THIS
PRODUCT.

First Aid:INHALATION:REMOVE VICTIM TO FRESH AIR AT ONCE. IF NOT
BREATHING, GIVE MOUTH-TO-MOUTH RESUSCITATION.IF BREATHING IS
DIFFICULT, GET IMMEDIATE MEDICAL ATTENTION.KEEP VICTIM WARM AND AT
REST.SKIN:WASH SKI N IMMEDIATELY WITH LOTS OF SOAP AND WATER.IF
CLOTHES AND SHOES ARE CONTAMINATED, REMOVE AND WASH BEFORE
REUSE.GET MEDICAL ATTENTION IF ILL EFFECT OR IRRITATION
DEVELOPS.EYES:WASH EYES IMMEDIATELY WITH RUNNING WATER FOR AT
LEAST 20 MINUTES.USE FINGERS TO ASSURE THAT EYELIDS ARE SEPARATED
AND THAT EYE IS BEING WASHED.LIFT THE LOWER AND UPPER LID
OCCASIONALLY.GET IMMEDIATE MEDICAL ATTENTION.INGESTION :DO NOT
INDUCE VOMITING

Flash Point Method:PMCC
Flash Point:=101.7C, 215.F
Autoignition Temp:=220.C, 428.F
Lower Limits:1.1
Upper Limits:6.0
Extinguishing Media:DRY CHEMICAL, ALCOHOL RESISTANT FOAM. CO2.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE BUT CAN BE USED TO
COOL CONTAINERS EXPOSED TO HEAT OR FLAME. CAUTION SHOULD BE
EXERCISED WHEN USING WATER OR FOAM AS FROTHING MAY OCCUR,
ESPECIALLY IF SPRAYED INTO CONTAINERS OF HOT, BURNING LIQUID.
Unusual Fire/Explosion Hazard:DENSE SMOKE MAY BE GENERATED WHILE
BURNING. CARBON MONOXIDE, CARBON DIOXIDE, AND OTHER OXIDES MAY BE
GENERATED AS PRODUCTS OF COMBUSTION. CONTAINERS EXPOSED TO INTENSE
HEAT FROM FIRES SHOULD BE COOL ED WITH WATER TO PREVENT VAPOR
PRESSURE BUILDUP WHICH COULD RESULT IN CONTAINER RUPTURE.

Spill Release Procedures:USE APPROPRIATE PROTECTIVE AND SAFETY
EQUIPMENT. SMALL SPILL: MOP UP OR SOAK UP WITH NON-COMBUSTIBLE
ABSORBENT INORGANIC MATERIAL. TRANSFER TO DOT-APPROVED CONTAINER.
LARGE SPILL: EVACUATE SPILL AR EA OF UNPROTECTED PERSONNEL.
CONTAIN BY DIKING WITH NON-COMBUSTIBLE ABSORBENT INORGANIC
MATERIAL. PREVENT RUNOFF FROM ENTERING SEWERS, STORM DRAINS,
SURFACE WATER, AND SOIL.

Handling and Storage Precautions:TRAIN ALL EMPLOYEES ON ALL SPECIAL
HANDLING PROCEDURES IN THIS SECTION BEFORE THEY WORK WITH THIS
PRODUCT.EXERCISE REASONABLE CARE & CAUTION.PERSONNEL SHOULD AVOID
BREATHING VAPORS &/OR MISTS, GETTING PRODUCT IN THE EYES OR ON THE
SKIN.KEEP CONTAINERS COOL, DRY, & AWAY FROM SOURCES OF IGNITION.
Other Precautions:DO NOT STORE PRODUCT IN DIRECT SUNLIGHT, HIGH
TEMPERATURE, OR BELOW FREEZING AREAS. KEEP PRODUCT CONTAINER
TIGHTLY CLOSED WHEN NOT IN USE. PROTECT CONTAINERS FROM PHYSICAL
DAMAGE. USE AND STORE WIT H ADEQUATE VENTILATION. DO NOT CUT,
WELD, GRIND, OR DRILL ON OR NEAR THIS CONTAINER. GROUND ALL EQ
UIPMENT.

Respiratory Protection:ATMOSPHERIC LEVELS SHOULD BE MAINTAINED BELOW
EXPOSURE GUIDELINES. WHEN RESPIRATORY PROTECTION IS REQUIRED FOR
CERTAIN OPERATIONS, USE A MSHA/NIOSH APPROVED FILTER TYPE
RESPIRATOR USED IN ACCORDANCE WITH THE REQUIREMENTS OF 29 CFR
1910.134.
Ventilation:CONTROL AIRBORN CONCENTRATIONS BELOW EXPOSURE GUIDELINES
WITH MECHANICAL VENTILATION, IF NECESSARY. LOCAL EXPLOSION-PROOF
EXHAUST VENTILATION MAY BE NECESSARY
Protective Gloves:IMPERMEABLE GLOVES
Eye Protection:SAFETY GLASSES OR CHEMICAL GOGGLES
Other Protective Equipment:SUITABLE LABORATORY SAFETY EQUIPMENT
INCLUDES SAFETY SHOWERS, EYE WASHES, AND PROPER FIRE EXTINGUISHING
MEDIA.
Work Hygienic Practices:DON'T CONSUME FOOD, DRINK, OR TOBACCO IN AREAS
WHERE THEY MAY BECOME CONTAIMINATED W/THIS MATERIAL. WASH
THOROUGHLY AFTER USING.
Supplemental Safety and Health
VAPOR PRESSURE OF VOC: 95 PSIG. HMIS CODES: HEALTH=1; REACTIVITY=0;
FLAMMABILITY=4; PERSONAL PROTECTION=G

Boiling Pt:B.P. Text:425-525 F
Melt/Freeze Pt:M.P/F.P Text:ND
Vapor Pres:0.05
Vapor Density:6.72
Spec Gravity:0.80
VOC Pounds/Gallon:779
pH:NA
Evaporation Rate & Reference:ND
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK PARTICLES SUSPENDED IN WATER WHITE
LIQUID;ODORLESS

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:NONE KNOWN.

Waste Disposal Methods:CONSULT APPROPRIATE FEDERAL, STATE AND LOCAL
REGULATORY AGENCIES TO ASCERTAIN PROPER DISPOSAL PROCEDURES.DO NOT
PUNCTURE, INCINERATE OR STORE ABOVE 120 DEG F.NOTE:COMPLY WITH ALL
APPLICABLE GOVERNMENT REGULATIONS ON SPILL REPORTING AND HANDLING
AND DISPOSAL OF WASTE.EMPTY CONTAINERS CAN HAVE RESIDUE S, GASES,
AND MISTS.

Transport Information:DOT INFORMATION: CONSUMER COMMODITY, ORM-D

SARA Title III Information:SARA TITLE III, SECT 302-304: THRESHOLD
PLANNING QUANTITY : NONE; REPORTABLE QUANTITY: NONE SARA TITLE
III, SECTION 311-12; ACUTE FIRE

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.