Product ID:FORMULA 150-PAINT, COMPONENT A, SEE SUPPLEMENTAL DATA
MSDS Date:02/24/2000
FSC:8010
NIIN:01-380-2362
Status Code:A
Kit Part:Y
MSDS Number: CLCQT

PRO-LINE PAINT CO

2646 MAIN STREET
SAN DIEGO, CA 92113-3697
US

Emergency Phone: 619-231-2313 /216-566-2917

Info Phone: 619-231-2313; 216-566-2902

Cage: 9D157

PRO-LINE PAINT CO

SAN DIEGO, CA 92113-3697 US

Telephone: 619-231-2313; 619-232-8968

Cage: 9D157

POLYAMIDE AMINE (CAS # TRADE SECRET)

BENZYL ALCOHOL

CAS: 100-51-6

RTECS: DN3150000

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3 (T DUST)

MAGNESIUM SILICATE

CAS: 14807-96-6

RTECS: WW2710000

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 2 MG/M3 AS DUST

N-BUTYL ALCOHOL

CAS: 71-36-3

RTECS: EO1400000

OSHA PEL 300 MG/M3;100 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: NAUSEA, DIZZINESS, HEADACHE,
AND CONVULSIONS. CHRONIC: POSSIBLE SKIN SENSITIZATION.
Explanation of Carcinogenicity:PROP 65 CA (THIS PRODUCT CONTAINS A
CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND BIRTH
DEFECTS OR OTHER REPRODUCTIVE HARM). CALIFORNIA EMPLOYERS USING
CAL/OSHA-REGULATED CARCINOGENS M UST REGISTER WITH CAL/OSHA.
Effects of Overexposure:INHALED: COUGHING, SHORTNESS OF BREATH, MAY
CAUSE DIZZINESS. CONTACT WITH SKIN OR EYES: BURNING SENSATION,
POSSIBLE RASH BREAKOUT. ABSORBED THROUGH SKIN: SKIN RASH MAY CAUSE
BURNING OF SKIN AND INFLAM MATION. SWALLOWED: VOMITING DUE TO
UNPLEASANT TASTE. MAY CAUSE DIARRHEA OR STOMACH CRAMPS.
RECOMMENDATIONS TO PHYSICIAN: CONSULT WITH POISON CONTROL CENTER.
FOR WORKERS WHO ARE EXPOSED REGULARLY, PRO VIDE DETAILED PERIODIC
EXAMINATIONS.
Medical Cond Aggravated by Exposure:ASTHMA, EMPHYSEMA, AND OTHER
RESPIRATORY DISEASES.

First Aid:EYE CONTACT: FLUSH IMMEDIATELY WITH FRESH WATER BY AN EYE
WASH APPARATUS OR BY HAND. SEEK MEDICAL ATTENTION. SKIN CONTACT:
WASH IMMEDIATELY WITH WATER. THEN WASH WITH SOAP AND WATER, RINSE
IMMEDIATELY . IF BURNING SENSATION, RASH BREAKOUT, OR OTHER
SYMPTOMS OCCUR SEEK MEDICAL ATTENTION. INHALED: MOVE PERSON TO
FRESH AIR. GIVE ARTIFICIAL RESPIRATION IF NECESSARY. SEEK MEDICAL
ATTENTION. IF SWALLOWED : SEEK MEDICAL ATTENTION:

Flash Point Method:SCC
Flash Point:=38.3C, 101.F
Autoignition Temp:Autoignition Temp Text:N/E
Lower Limits:N/E
Upper Limits:N/E
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM AND DRY CHEMICAL.
Fire Fighting Procedures:BLANKET FLAME WITH ONE OF THE ABOVE. DO NOT
ENTER FIRE AREA WITHOUT PROPER PROTECTION AND EQUIPMENT INCLUDING
NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:KEEP MATERIAL AWAY FROM HEAT, SPARKS AND
OPEN FLAME EXPLOSIVE WHEN HEATED. STAY A SAFE DISTANCE FROM FIRE
WHEN EXTINGUISHING.

Spill Release Procedures:REMOVE ALL TYPES OF IGNITION SOURCES. PROVIDE
SUFFICIENT VENTILATION. PROTECT CLEANUP MAN WITH NIOSH APPROVED
RESPIRATOR, GOGGLES AND RUBBER GLOVES. (NOTE RESPIRATORY PROTECTION
SECTION).

Handling and Storage Precautions:TRAIN EMPLOYEES ON ALL SPECIAL
HANDLING PROCEDURES BEFORE WORKING WITH PRODUCT. KEEP IN DRY AREA
AT ROOM TEMPERATURE, 77F PLUS OR MINUS 5 DEGREES. PREVENT CANS FROM
CORROSION AND CONSEQUENTLY, SPILLA GE. WASH CONTAMINATED EQUIPMENT
WITH FRESH WATER BEFORE MAINTENANCE.
Other Precautions:WARNING ! DETECTABLE AMOUNTS OF CHEMICALS OR
SUBSTANCES KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH
DEFECT, OR OTHER REPRODUCTIVE HARM MAY BE FOUND IN CHEMICAL
PRODUCTS, PETROLEUM PRODUCTS , AND THEIR VAPORS. FOLLOW APPLICABLE
DIRECTION AND USE CARE WHEN HANDLING CHEMICAL AND PETROLEUM PR
ODUCTS.

Respiratory Protection:USE DUST/MIST RESPIRATOR (HIGH EFFICIENCY
CARTRIDGES ADVISED) IF SPRAYING OR SANDING. USE NIOSH APPROVED
ORGANIC VAPOR RESPIRATOR AND SPRAY PAINT PRE-FILTER IF TLV OR
SOLVENT COMPONENTS MAY BE EXCEEDE D. WHEN USING IN CONFINED AREA,
WEAR AIR-FED HOOD.
Ventilation:USE LOCAL EXHAUST WHEN APPLYING THIS PAINT IN CONFINED
AREAS. KEEP VAPORS BELOW TLV.
Protective Gloves:RUBBER GLOVES.
Eye Protection:GOGGLES WITH SIDE SHIELD.
Other Protective Equipment:USE PROTECTIVE CLOTHING AND CHANGE
CONTAMINTED CLOTHING IMMEDIATELY. PROVIDE EMERGENCY SHOWERS AND
EYEWASH AT STATIONARY PAINT APPLICATION FACILITIES.
Work Hygienic Practices:TRAIN EMPLOYEES ON ALL SPECIAL HANDLING
PROCEDURES IN THIS SECTION BEFORE THEY WORK WITH THIS PRODUCT.
Supplemental Safety and Health
PRODUCT ID CONT: EPOXY-POLYAMIDE, GREEN PRIMER, MIL-P-24441/29 (SH)
TYPE IV, 2 COMPONENT PAINT, COMPONENT A & B MIXED. THIS ENTRY
DESCRIBES PART A OF A TWO PART KIT. SEE THIS SAME NSN AND CAGE CODE
FO R PART B DATA.

HCC:F4
Boiling Pt:B.P. Text:NOT EST
Melt/Freeze Pt:M.P/F.P Text:NOT EST
Vapor Pres:NOT EST
Vapor Density:NOT EST
Spec Gravity:1.39
VOC Pounds/Gallon:264
Evaporation Rate & Reference:NOT EST (BUTYL ACETATE=1)
Solubility in Water:POOR
Appearance and Odor:TYPICAL PAINT APPEARANCE WITH STRONG SOLVENT ODOR
TYPICAL OF BUTANOL.

Stability Indicator/Materials to Avoid:YES
WHEN A & B ARE MIXED, KEEP AWAY FROM HEAT, HEAT WILL CREATE A RAPID
CHEMICAL REACTION. EMITS HEAT.
Stability Condition to Avoid:HEAT, SPARKS, AND OPEN FLAMES. DO NOT
ALLOW VAPOR TO ACCUMULATE.
Hazardous Decomposition Products:COMBUSTABLE FUMES MAY ACCUMULATE IN
CONFINED AREA AND SPARKS OR OPEN FLAMES MAY IGNITE IT.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:USE METAL CONTAINER MARKED "DO NOT REUSE". PUT
THE MATERIAL IN THIS CONTAINER. USE VERMICULITE OR OTHER ABSORBENT.
KEEP AWAY FROM SEWER. DISPOSE OF ALL WASTES IN ACCORDANCE WITH
FEDERAL, STATE, AND LO CAL REGULATIONS.

Toxicological Information:MANUFACTURER STATES UNIDENTIFIED INGREDIENTS
ARE NOT CONSIDERED HAZARDOUS UNDER THE FEDERAL HAZARD COMMUNICATION
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:UN SHIPPING NAME: PAINT; U.N. LABEL: FLAMMABLE
LIQUID;. UN 1263 ; CLASS 3; PKG I I I.

State Regulatory Information:DETECTABLE AMOUNTS OF CHEMICALS OR
SUBSTANCES KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH
DEFECTS, OR OTHER REPRODUCTIVE HARM MAY BE FOUND IN CHEMICAL
PRODUCTS, PETROLEUM PRODUCTS, AND THE IR VAPORS. FOLLOW APPLICABLE
DIRECTIONS AND USE CARE WHEN HANDLING CHEMICAL PRODUCTS. (
CALIFORNIA HEALTH AND SAFETY CODE SECTION25249-6). CALIFORNIA
EMPLOYERS USING CAL/OSHA-REGULATED CARCINOGENS MUS T REGISTER WITH
CAL/OSHA. THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER AND BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM.