Product ID:N4787A HI IR 686 TAN
MSDS Date:03/16/2001
FSC:8010
NIIN:01-260-0909
Status Code:A
Kit Part:Y
MSDS Number: CLFZZ

NILES CHEMICAL PAINT

225 FORT STREET
NILES, MI 49120
US

Emergency Phone: 800-424-9300

Info Phone: 616-683-3377/219-236-5856

Preparer: RYAN MICKELSON

Cage: 02388

NILES CHEMICAL PAINT

307 NILES, MI 49120 US

Telephone: 616-683-3377/219-236-5856

Cage: 02388

CRYSTALLINE SILICA

CAS: 14808-60-7

RTECS: VV7330000

OSHA PEL see Table Z-3

ACGIH TLV: 0.1 MG/M3

2-PROPANOL, 1-METHOXY-, ACETATE

CAS: 108-65-6

RTECS: AI8925000

TITANIUM DIOXIDE

CAS: 1317-80-2

RTECS: VM2940000

POLYESTER RESIN

BUTYL ACETATE

CAS: 123-86-4

RTECS: AF7350000

OSHA PEL 710 MG/M3;150 PPM

ACGIH TLV: 713 MG/M3;150 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

XYLOL

CAS: 1330-20-7

RTECS: ZE2100000

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

DIATOMACEOUS EARTH

CAS: 61790-53-2

RTECS: VV7311000

OSHA PEL see Table Z-3

ACGIH TLV: 10 MG/M3

METHYL ETHYL KETONE

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 590 MG/M3;200 PPM

ACGIH TLV: 590 MG/M3;200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL PROPYL KETONE

CAS: 107-87-9

RTECS: SA7875000

OSHA PEL 700 MG/M3;200 PPM

ACGIH TLV: 705 MG/M3;200 PPM

CHROMIC OXIDE

CAS: 1308-38-9

RTECS: GB6475000

Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: EYES: SEVERE IRRITATION,
LACRIMATION, REDNESS, BLURRED VISION. SKIN: REDNESS AND IRRITATION,
DEFATTING OF THE SKIN LEADING TO DERMATITIS. BREATHING: NASAL
RESPIRATORY IRRITATION, CNS DEPRESSION NAUSEA, HEADACHE, VERTIGO,
POSSIBLE UNCONSCIOUSNESS, EVEN ASPHIXIATION. SWALLOWING:
GASTOINTESTINAL IRRITATION, ABDOMINAL PAIN, NAUSEA, VOMITING,
DIARRHEA. CHRONIC: LIVER KIDNEYS, NONE KNOWN, HISTOLO GIC FIBROSIS
OF LUNGS. EYE SKIN AND RESPIRATORY IRRIATION. NARCOSIS, COMA, UPPER
RESPIRATORY TRACT, PULMONARY FIBROSIS, INCOHERENCE, CORNEAL
VACUOLIZATION, ANOREXIA.
Explanation of Carcinogenicity:CONTAINS <0.5% CRYSTALLINE SILICA
Effects of Overexposure:LIVER KIDNEYS NONE KNOWN RESPIRATORY SYSTEM,
CNS, LUNGS, EYES, SKIN, UPPER RESPIRATORY TRACT, GI TRACT, BLOOD,
LIVER, KIDNEY.

First Aid:INHALATION: MOVE VICTIM TO FRESH AIR AT ONCE. GET MEDICAL
ATTENTION AS SOON AS POSSIBLE. SKIN CONTACT: FLUSH SKIN WITH PLENTY
OF WATER. GET MEDICAL ATTENTION. EYE CONTACT: FLUSH EYES WITH LARGE
AMOUNT S OF WATER FOR AT LEAST 15 MINUTES, OCCASIONALLY LIFTING
UPPER AND LOWER LIDS. GET MEDICAL ATTENTION IMMEDIATELY.
SWALLOWING: DRINK 1 OR 2 GLASSES OF WATER. DO NOT INDUCE VOMITING.
CONSULT A PHYSICIA N OR POISON CONTROL CENTER IMMEDIATELY.

Flash Point Method:TCC
Flash Point:=-3.7C, 25.F
Lower Limits:1.1
Upper Limits:12.0
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN POSITIVE PRESSURE MODE AND FULL
PROTECTIVE CLOTHING. WATER MAY BE USED TO COOL CONTAINERS TO
PREVENT PRESSURE BUILD UP AND POS SIBLE AUTO IGNITION OR EXPLOSION
WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. VAPORS
ARE HEAVIER THAN AIR AND MAY TRAVEL ALONG THE GROUND TO AN IGNITION
SOURCE. ISOLATE FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT, AND OPEN
FLAMES. CLOSED CONTAINERS M AY EXPODE WHEN EXPOSED TO EXTREME HEAT.
APPLICATION TO HOT SURFACES REQUIRES SPECIAL PRECAUTIONS. DURING
EMERGENCY COND

Spill Release Procedures:SMALL AND LARGE SPILLS: MINIMIZE THE BREATHING
OF VAPORS AND AVOID SKIN CONTACT. DIKE TO PREVENT FURTHER MOVEMENT
AND RECLAIM INTO RECOVERY OR SALVAGE DRUMS OR TANK TRUCK FOR
DISPOSAL.

Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. AVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY, DO NOT WELD OR FLAME CUT ON EMPTY DRUMS. SHOCK FROM DROPPING
MAY SPLIT CONTAINER.

Respiratory Protection:WEAR AN APPROPRIATE (TYPE TC-23C-49) PROPERLY
FITTED HALF-MASK OR FULL FACEPIECE RESPIRATOR.
Ventilation:SUFFICIENT VENTILATION IN VOLUME AND PATTERN SHOULD BE
PROVIDED.
Protective Gloves:WEAR CHEMICAL RESISTANT (NITRILE OR VITON) GLOVES.
Eye Protection:WEAR CHEMICAL GOGGLES, SAFETY GLASSES, OR FACE SHIELDS.
Other Protective Equipment:EMPLOYEES SHOULD WASH PROMPTLY WHEN SKIN
BECOMES CONTAMINATED. REMOVE ANY CLOTHING THAT BECOMES WET.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
RESTROOM.
Supplemental Safety and Health

Boiling Pt:B.P. Text:175-302F
Spec Gravity:1.412
Viscosity:70-85KU
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID ODOR OF SOLVENTS
Percent Volatiles by Volume:60.76
Corrosion Rate:MINIMAL

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ACIDS, NONE KNOWN, STRONG OXIDIZERS AND CHLORONATED
COMPOUNDS, NITRATES, ALKALIES, HYDROPLOURIC ACID.
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE, AND FEDERAL REGULATIONS.

Federal Regulatory Information:SECTION 302-EXTREMELY HAZARDOUS
SUBSTANCES (40 CFR 355): THIS PRODUCT DOES NPT CONTAIN INGREDIENTS
LISTED IN APPENDIX A AND B AS AN EXTREMELY HAZARDOUS SUBSTANCE.
SECTION 311AND 312-M.S.D.S. REQUIREME NTS (40 CFR 370): OUR HAZARD
EVALUATION HAS FOUND THIS PRODUCT TO BE HAZARDOUS . THE PRODUCT
SHOULD BE REPORTED UNDER THE FOLLOWING EPA HAZARD CATOGORIES: [X]
IMMEDIATE (ACUTE) HEALTH HAZARD: [X] DELA YED (CHRONIC)
HEALTHHAZARD:[X] FIRE HAZARD:SUDDEN RELEASE OF PRESSURE HAZARD:
REACTIVITY HAZARD: SEC TION 313-LIST OF TOXIC CHEMICALS(40 CFR
372): PRODUCT CONTAINS METHYL ETHYL KETONE, XYLENE
State Regulatory Information:

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.