Product ID:MIL-L-81352A #34102 GREEN
MSDS Date:07/14/1998
FSC:8010
NIIN:00-068-8783
Status Code:A
MSDS Number: CLGSB

GRIGGS PAINT

3602 S 16TH PLACE
PHOENIX, AZ 85040
US

Emergency Phone: 800-424-9300

Info Phone: 602-243-3293

Preparer: ERNEST CARTER

Cage: 58963

GRIGGS PAINT

PHOENIX, AZ 85040 US

Telephone: 602-243-3293

Cage: 58963

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

MAGSIL 2628

CAS: 14807-96-6

RTECS: WW2710000

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 2 MG/M3

LD50 LC50 Mixture:NONE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:DIRECT CONTACT TO EYES MAY CAUSE
IRRITATION. PROLONGED AND/OR REPEATED CONTACT MAY CAUSE SKIN
IRRITATION. INHALATION OF HIGH CONCENTRATIONS OF VAPORS MAY LEAD TO
LUNG CHANGES, NAUSEA, VOMITING, COUG H, PULMONARY IRRITATION, AND
CENTRAL NERVOUS SYSTEM DEPRESSION. INGESTION MAY CAUSE
GASTROINTESTINAL DISTURBANCES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: BREATHING OF HIGH VAPOR
CONCENTRATIONS MAY CAUSE DROWSINESS, DIZZINESS, FATIGUE, FOLLOWED
BY COMA. EYE: DIRECT CONTACT AND/OR CONTACT WITH VAPORS MAY CAUSE
IRRITATION. SKIN: PROLONGED AND/ OR REPEATED CONTACT MAY CAUSE
IRRITATION AND/OR DERMITITIS. MAY BE ABSORBED THROUGH THE SKIN.
ASPIRATION OF THIS PRODUCT INTO LUNGS MAY CAUSE PNEUMONTITIS,
PULMONARY EDEMA AND HEMORRAGE. INGESTION MAY CAUSE
GASTROINTESTINAL DISTURBANCES.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES IN OR HISTORY OF AILMENTS INVOLVING SKIN CENTRAL NERVOUS
SYSTEM, LIVER AND KIDNEY.

First Aid:EYE CONTACT: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER
FOR 15 MINUTES. SEEK MEDICAL AID. SKIN: WASH THROUGHLY WITH SOAP
AND WATER. SEEK MEDICAL AID. INGESTION: IMMEDIATELY SEEK MEDICAL
AID.

Flash Point Method:TCC
Flash Point:80 DEG F.
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:1.0%
Upper Limits:NONE
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:APPROVED GAS MASK REQUIRED FOR FIRE FIGHTING
PERSONEL. WATER MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL
CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO HEAT.

Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCES OF IGNITION. STAY UPWIND. ABSORB WITH INERT MATERIAL. FLUSH
AREA WITH WATER.
Neutralizing Agent:NONE

Handling and Storage Precautions:KEEP CONTAINERS CLOSED AND UPRIGHT TO
PREVENT LEAKAGE. AVOID FLAMES, WELDING, OPEN LIGHTS, ETC. AVOID
BREATHING OF VAPOR AND SPRAY MIST. AVOID SKIN AND EYE CONTACT.
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TANK OR PIT, WITHOUT ADEQUATE VENTILATION.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW TLV (PEL), USE MSHA/NIOSH APPROVED UNITS. USE UNITS
PER CURRENT 29 CFR 1910.134 AND FOLLOW MANUFACTURERS' INSTRUCTIONS
AND WARNINGS. IF WITH IN OSHA PROTECTION FACTOR, AIR PURIFYING
OV/FILTER UNITS OK FOR USE.
Ventilation:LOCAL AND MECHANICAL EXHAUST.
Protective Gloves:RUBBER GLOVES.
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS OR GOGGLES.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER.
Work Hygienic Practices:MAINTAIN GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
AS THE CONDITIONS OR METHODS ARE BEYOUND OUR CONTROL, WE DO NOT ASSUME
ANY RESPONSIBILITY REGARDING USE OF PRODUCT. WE EXPRESSLY DISCLAIM
ANY LIABILITY FORANY USE OF THE MATERIAL. INFORMATION CONTAIN ED
HEREIN IS BELIEVED TO BE ACCURATE ALL STATEMENTS OR SUGGESTIONS
ARE MADE.

Boiling Pt:=137.8C, 280.F
Melt/Freeze Pt:M.P/F.P Text:NONE
Decomp Temp:Decomp Text:NONE
Vapor Density:HEAVIER
Spec Gravity:(H2O=1):1.1
VOC Pounds/Gallon:561
VOC Grams/Liter:4.68
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTINAL NIL.
Appearance and Odor:VISCOUS LIQUID WITH STRONG SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING AND HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:USE INERT ABSORBENT MATERIALS ON SPILLS. DISPOSE
OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.