Product ID:#125 FLUX
MSDS Date:01/15/1999
FSC:3439
NIIN:00-220-3827
Status Code:A
MSDS Number: CLGTS

QUALITEK INTL INC

315 FAIRBANK ST
ADDISON, IL 60101
US

Emergency Phone: 1-800-535-5053

Cage: 0N5C3

QUALITEK INTL INC

ADDISON, IL 60101 US

Telephone: 1-630-628-8083

Cage: 0N5C3

2-PROPANOL

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

ROSIN

CAS: 8050-09-7

RTECS: VL0480000

OSHA PEL N/E

ACGIH TLV: N/E

NO OTHER HAZARDOUS INGREDIENTS EXCEED 1%. OTHER INGREDIENTS

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALTION OF FUMES OR INGESTION
MAY CAUSE HEADACHE, NAUSEA, MUSCULAR PAIN, IRRITATION OF EYE AND
NOSE MAY RESULT FROM CONTACT WITH SOLDERING FUMES. CHRONIC: ANEMIA,
INSOMIA, WEAKNESS, CONSTIPAT ION AND ABDOMINAL PAINS DUE TO
INGESTION, SKIN, RASH, DAMAGE TO MUCOUS MEMBRANES DUE TO SKIN
EXPOSURE AND INHALATION.
Explanation of Carcinogenicity:NONE ACCORDING TO NTP, IARC AND OSHA.
Effects of Overexposure:IRRITATION OF PULMONARY SYSTEM, SKIN RASH.
Medical Cond Aggravated by Exposure:PRE-EXISTING CONDITIONS OF THE
LUNGDS, DISEASES OF THE BLOOD AND BLOOD FORMING ORGANS: KIDNEYS,
NERVES, AND POSSIBLY REPRODUCTIVE SYSTEMS.

First Aid:PERFORM THE FOLLOWING FIRST AID PROCEDURES; CONSULT A
PHYSICIAN & GET POPER MEDICAL ATTENTION WHEN NECESSARY. IN CASE OF
CONTACT WITH SMOKE FROM SOLDERING OR REPEATED SKIN CONTACT. EYE
CONTACT: FLUSH EYES WITH PLENTY OF WATER FOR 15 MINUTES. SKIN
CONTACT: WASH THROUGHLY WITH SOAP AND WATER, USE LOTION TO PREVENT
DRYNESS. INHALATION: REMOVE PERSON TO FRESH AIR. INGESTION: DRINK A
LOT OF WATER, DO N OT INDUCE VOMITING AND GET PROPER MEDICAL
ATTENTION.

Flash Point:=11.7C, 53.F
Autoignition Temp:=440.6C, 825.F
Lower Limits:205
Upper Limits:12
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL OR ALCOHOL FOAM.
Fire Fighting Procedures:SCBA WITH FULL FACE PIECE AND PROTECTIVE
CLOTHING IS RECOMMEDED.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT.

Spill Release Procedures:SMALL SPILLS SHOULD BE CLEANED UP WITH
ABSORBENT,LARGE SPILLS SHOULD BE COLLECTED FOR DISPOSAL.

Handling and Storage Precautions:DO NOT STORE OR USE NEAR SPARK OR
FLAME. KEEP CONTAINERS CLOSED TIGHTLY AND UPRIGHT TO PREVENT
LEAKAGE.
Other Precautions:AVOID REPEATED OR PROLONGED BREATHING OF VAPOR OR
SKIN CONTACT.

Respiratory Protection:USUALLY NOT REQUIRED. WHEN VENTILATION IS NOT
ADEQUATE TO REMOVE SMOKE (DURING SOLDERING) FROM BREATHING ZONE A
CARTRIDGE TYPE RESPIRATOR IS NEEDED.
Ventilation:AS REQUIRED KEEP PEL & TLV BELOW THE LIMIT.
Protective Gloves:NEOPRENE OR RUBBER.
Eye Protection:SPLASH GUARD GOGGLES.
Other Protective Equipment:NOT REQUIRED.
Work Hygienic Practices:WASH HANDS AFTER HANDLING PRODUCT. AVOID
PROLONGED OR REPEATED CONTACT WITH SKIN OR BREATHING OF VAPORS.
Supplemental Safety and Health

HCC:F2
Boiling Pt:=82.5C, 180.5F
Vapor Pres:33.00 @88F
Vapor Density:2.07
Spec Gravity:0.8844/-0.005
Evaporation Rate & Reference:<2.30
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT AMBER LIQUID WITH MILD ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Hazardous Decomposition Products:MAY RELEASE TOXIC VAPOR/GASES SUCH AS
CARBON MONOXIDE, CARBON DIOXIDE.

Waste Disposal Methods:DISPOSAL IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT: DOT PROPER SHIPPING NAME-FLAMMABLE LIQUID,
N.O.S. (CONTAINS ISPROPYL ALCOHOL), 3, UN1993, II.

SARA Title III Information:SECTION 311/312-THIS PRODUCT IS CLASSIFIED
INTO THE FOLLOWING HAZARD CATEGORIES: IMMEDIATE HEALTH, DELAYED
HEALTH, FIRE. SECTION 313-THIS PRODUCT IS NOT SUBJECT TO THE
COMMUNITY RIGHT-TO-KNOWN REPORTI NG REQUIREMENTS.
Federal Regulatory Information:TSCA: SUBJECT CHEMICAL SUBSTANCE(S) AND
INGREDIENT(S) ARE ALL LISTED ON THE TSCA INVENTORY OF CHEMICAL
SUBSTANCES MAINTAINED BY THE U.S ENVIRONMENTAL PROTECTION AGENCY.
CERCLA: IF THIS PRODUCT IS ACCI DENTALLY SPILLED, IT IS NOT SUBJECT
TO ANY SPECIAL REPORTING REQUIREMENTS OF THE COMPREHENSIVE
ENVIRONMENTAL RESPONSE, COMPENSATION AND LIABILITY ACT (CERCLA)
CONTACT LOCAL AUTHORITIES TO DETERMINE IF THERE ARE ANY LOCAL
REPORTING REQUIREMENTS.
State Regulatory Information:CALIFORNIA PROPOSITION 65: THIS PRODUCT
WHEN USED FOR SOLDERING AND SIMILAR APPLICATIONS PRODUCES CHEMICALS
KNOWN TO THE STATE TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.