Product ID:G-6381, TELEDYNE BATTERY, GILL AIRCRAFT BATTERY (SEE SUPPL)
MSDS Date:03/01/2000
FSC:6140
NIIN:01-214-0353
Status Code:A
MSDS Number: CLGYW

TELEDYNE BATTER PRODUCTS, TELEDYNE INC COMPANY

840 W BROCKTON AVE
REDLANDS, CA 92375
US

Emergency Phone: 909-793-3131

Info Phone: 909-793-3131

Preparer: NAHID TOOSSI

Cage: 84375

TELEDYNE BATTER PRODUCTS, TELEDYNE INC COMPANY

431 REDLANDS, CA 92373 US

Telephone: 909-793-3131

Cage: 84375

LEAD AND LEAD COMPOUNDS

CAS: 7439-92-1

RTECS: OF7525000

OSHA PEL 50 UG/M3

ACGIH TLV: 0.15 MG/M3

ANTIMONY

CAS: 7440-36-0

RTECS: CC4025000

OSHA PEL 0.5 MG/M3

ACGIH TLV: 0.5 MG/M3

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ARSENIC

CAS: 7440-38-2

RTECS: CG0525000

OSHA PEL 10 UG/M3

ACGIH TLV: 0.01 MG/M3

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

BARIUM SULFATE

CAS: 7727-43-7

RTECS: CR0600000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

CALCIUM COMPOUNDS

CAS: 7440-70-2

RTECS: EV8040000

OSHA PEL 5 MG/M3

ACGIH TLV: 2 MG/M3

CARBON BLACK EXTRACTS

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

TIN COMPOUNDS

CAS: 7440-31-5

RTECS: XP7320000

OSHA PEL 2 MG/M3

ACGIH TLV: 2 MG/M3

LD50 LC50 Mixture:NOT PROVIDED
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE OVEREXPOSURE: ACUTE UNTREATED
OVEREXPOSURE TO LEAD MAY LEAD TO WEAKNESS, VOMITING, LOSS OF
APPETITE, UN-COORDINATED BODY MOVEMENTS, CONVULSIONS, STUPOR,
POSSIBLY COMA. CHRONIC OVEREXPOSURE: CHRO NIC UNTREATED EXPOSURE TO
LEAD MAY CAUSE WEAKNESS, INSOMNIA, HYPERTENSION, SLIGHT IRRITATION
TO SKIN AND EYES, METALLIC TASTE, ANEMIA, CONSTIPATION, HEADACHE,
MUSCLE AND JOINT PAINS, NEUROMUSCULAR DYS FUNCTION, POSSIBLE
PARALYSIS, ENCEPHALOPATHY, PNEUMOCONIOSIS. LEAD CAN POSE RISK TO
DEVELOPING FETUSES AND MAY ALSO IMPAIR REPRODUCTIVE SYSTEMS IN BOTH
MEN AND WOMEN. DAMAGE TO THE KIDNEYS, HEMATOPOIE TIC AND/OR CNS MAY
OCCUR.
Explanation of Carcinogenicity:CONTAINS LEAD. ARSENIC IS LESS THAN 0.1
%.
Effects of Overexposure:OVEREXPOSURE TO LEAD MAY LEAD TO WEAKNESS,
VOMITING, LOSS OF APPETITE, UN-COORDINATED BODY MOVEMENTS,
CONVULSIONS, POSSIBLY COMA.
Medical Cond Aggravated by Exposure:NOT PROVIDED

First Aid:EYES: (DRY OXIDE) WASH IMMEDIATELY WITH LARGE AMOUNTS OF
WATER. LIFTING THE LOWER AND UPPER LIDS CONTINUOUSLY. GET MEDICAL
ATTENTION. SKIN: NOT A DIRECT ROUT OF ENTRY. INHALATION: REMOVE
EMPLOYEE FROM AREA OF EXPOSURE. GET IMMEDIATE MEDICAL ATTETNION.
INGESTION: GET IMMEDIATE MEDICAL ATTENTION.

Flash Point:=357.2C, 675.F
POLYPROPYLENE
Extinguishing Media:USE HALON. DRY CHEMICAL EXTINGUISHER. BATTERY CASE
WILL BURN.
Fire Fighting Procedures:USE OF WATER IN EXTINGUISHING BURNING
BATTERIES MAY CAUSE SPATTERING DUE TO THE PRESENCE OF MOLTEN LEAD.
Unusual Fire/Explosion Hazard:WHILE BATTERY IS BEING CHARGED, HYDROGEN
GAS IS PRODUCED. BATTERY MAY EXPLODE IF HYDROGEN GAS IS TRAPPED
INSIDE THE BATTERY CASE. KEEP IGNITION SOURCES AWAY.

Spill Release Procedures:PICK UP AND CONTAINERIZE BATTERY PARTS AND
MATERIALS. LIMIT PERSONAL EXPOSURE WITH GLOVES, EYE, AND FACE
PROTECTION. WHEN BATTERY IS FILLED WHEN SULFURIC ACID ELECTROLYTE.
ISOLATE THE AREA SHOULD A BA TTERY BREAK OPEN. ELECTROLYTE SHOULD
BE ABSORBED WITH A NON-ORGANIC TYPE ABSORBENT SUCH AS DRY SAND OR
EARTH. AVOID DILUTION WITH WATER. LEAD SPILLED FROM BATTERY SHOULD
BE HEPA VACUUMED/ WET MOPPED.
Neutralizing Agent:NOT PROVIDED

Handling and Storage Precautions:EXERCISE CAUTION IN HANDLING AND
STORAGE DUE TO WEIGHT OF UNITS.
Other Precautions:USE CAUTION WHEN FILLING UNTIS WITH ELECTROYLTE
(BATTERY ACID, DILUTE SULFURIC ACID). WEAR ACID RESITANT PLASTIC OR
RUBBER GLOVES, EYE PROTECTION, APRON AND BOOTS. MATERIAL SAFETY
DATA SHEET FOR LEAD- ACID BATTERY APPLIES WHEN FILLED WITH ACID
ELECTROLYTE.

Respiratory Protection:UNDER NORMAL CONDITIONS OF USE RESPIRATORY
PROTECTION IS NOT REQUIRED. HOWEVER, SHOULD CONDITIONS ARISE WHERE
RESPIRATORS ARE NEEDED, USE ONLY NIOSH/MSHA RESPIRATORS APPROVED
FOR DUST, FUME AND MIST.
Ventilation:BATTERY CHARGING AREAS MUST BE ADEQUATELY VENTILATED TO
PREVENT HAZARDOUS CONCENTRATIONS OF FLAMMABLE GAS OR ACID MIST.
Protective Gloves:GLOVES APPROVED FOR SULFURIC ACID.
Eye Protection:CHEMICAL GOGGLES, FULL FACE SHIELD.
Other Protective Equipment:ACID RESISTANT APRON.
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
CONTD FROM PRODUCT ID: CENTURION, BIG BEAM, TELSTAR, SILTRON, AIR
TRACTOR AND SCHWIEZER. PART NUMBER: G-6381E. THIS MSDS DESCRIBES A
DRY BATTERY. FOR ACID ELECTROLYTE, SEE MSDS NUMBER CLGYZ.

HCC:Z7
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:>160.C, 320.F
B.P. Text:POLYPROPYLENE
Melt/Freeze Pt:=327.2C, 621.F
M.P/F.P Text:LEAD
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:(LEAD): NEGLIGIBLE
Spec Gravity:(LEAD) 11.34
Solubility in Water:(LEAD):INSOLUABLE IN WATE
Appearance and Odor:NO ODOR. BATTERY CASE IS PINK, WHITE, OLIVE GREEN,
OFF-WHITE, OR BLACK.
Percent Volatiles by Volume:NEGLIGIBLE
Corrosion Rate:NOT PROVIDED

Stability Indicator/Materials to Avoid:YES
CONTACT OF LEAD WITH STRONG OXIDIZERS MAY LIBERATE HYDROGEN GAS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:NONE

Waste Disposal Methods:BATTERY PARTS MAY BE RECYCLED BY AN
EPA-PERMITTED SECONDARY LEAD SMELTING FACILITY OR DISPOSED OF AS
HAZARDOUS WASTE PURSUANT TO RCRA REQUIREMENTS.

Toxicological Information:NOT PROVIDED

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NOT PROVIDED

Transport Information:NOT PROVIDED

SARA Title III Information:THE CHEMICALS LISTED BELOW ARE TOXIC
CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT
(SARA) OF 1986 AND 40 CFR PART 372: LEAD AND LEAD COMPOUNDS (CAS #
7439-92-1) <95%. ANTIMONY (CAS # 7440-38-0) <1.1%. ARSENIC (CAS #
7440-*38-2) <0.1%.
Federal Regulatory Information:NOT PROVIDED
State Regulatory Information:PROPOSITION 65 WARNING: BATTERY POSTS,
TERMINALS AND RELATED ACCESSORIES CONTAIN LEAD AND LEAD COMPOUNDS.
CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND
REPRODUCTIVE HARM. WASH HANDS A FTER HANDLING.