Product ID:PYROIL CARB & CHOKE CLEANER 12/13 OZ
MSDS Date:06/05/2000
FSC:6850
NIIN:01-085-1423
Status Code:A
MSDS Number: CLHCH

VALVOLINE OIL CO

3499 BLAZER PKY
LEXINGTON, KY 40512
US

Emergency Phone: 1-800-274-5263

Info Phone: 606-357-7206 / 800-274-5263

Cage: 72527

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ALCOHOL

CAS: 67-56-1

RTECS: PC1400000

OSHA PEL 260 MG/M3;200 PPM

ACGIH TLV: 262 MG/M3;200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACETONE

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 2400 MG/M3;1000 PPM

ACGIH TLV: 1780 MG/M3;750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

OSHA PEL 9000 MG/M3;5000 PPM

ACGIH TLV: 9000 MG/M3;5000 PPM

ETHYLBENZENE

CAS: 100-41-4

RTECS: DA0700000

OSHA PEL 435 MG/M3;100 PPM

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN: CAN CAUSE SKIN IRRITATION.
PASSAGE THROUGH THE SKIN MAY ADD TO TOXIC EFFECTS FROM BREATHING OR
SWALLOWING. SWALLOWING: MAY BE HARMFUL. ASPIRATION HAZARD. THIS
REULTS IN LUNG INFLAMMATION/ LUNG I NJURY. INHALATION: BREATHING
AEROSOL AND/OR MIST IS POSSIBLE WHEN MATERIAL IS SPRAYED. AEROSOL
AND MIST MAY PRESENT A GREATER RISK OF INJURY BECAUSE MORE MATERIAL
MAY BE PRESENT IN THE AIR THAN FROM V APOR ALONE. BREATHING SMALL
AMOUNTS OF THIS MATERIAL DURING NORMAL HANDLING IS NOT LIKELY TO
CAUSE HARMFUL EFECTS. BREATHING LARGE AMOUNTS MAY BE HARMFUL.
TARGET ORGANS: LIVER, KIDNEY, LUNGS, HEART, P ANCREAS & BRAIN.
Explanation of Carcinogenicity:THIS MATERIAL IS NOT EXPECTED TO CAUSE
CANCER IN HUMANS SINCE IT DID NOT CAUSE CANCER IN
LABORATORYANIMALS. THIS MATERIAL IS NOT LISTED AS A CARCINOGEN.
Effects of Overexposure:MOUTH AND THROAT IRRITATION (SORENESS, DRY OR
SCRATCHY FEELING, COUGH), STOMACH OR INTESTINAL UPSET (NAUSEA,
VOMITING, DIARRHEA), IRRITATION (NOE, THROAT, AIRWAYS), COUGH,
TIGHT FEELING IN THE CHEST, CENTRAL NERVOUS SYSTEM DEPRESSION
(DIZZINESS, DROWSINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
UNCONSCIOUSNESS) AND OTHER CENTRAL NERVOUS SYSTEM EFFECTS, LEG
CRAMPS, PAIN IN THE ABDOMEN AND LOWER BACK , RESPIRATORY DEPRESSION
(SLOWING OF THE BREATHING RATE), BLURRED VISION, SHORTNESS OF
BREATH, CYANOSIS (CAUSES BLUE COLORING OF THE SKIN AND NAILS FROM
LACK OF OXYGEN), HIGH BLOOD SUGAR, NARCOSIS (DA ZED OR SLUGGISH
FEELING, VISUAL

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES WHILE HOLDING
EYELIDS APART; SEEK IMMEDIATE MEDICAL ATTENTION. SKIN: REMOVE
CONTAMINATED CLOTHING. FLUSH EXPOSED AREA WITH LARGE AMOUNT OF
WATER. IF SKI N IS DAMAGED/SYMPTOMS PERSIST, SEEK IMMEDIATE
MEDICAL ATTENTION. SWALLOWING: SEEK MEDICAL ATTENTION. IF
INDIVIDUAL IS DROWSY OR UNCONSCIOUS, DO NOT GIVE ANYTHING BY MOUTH;
PLACE INDIVIDUAL ON THE LEF T SIDE WITH THE HEAD DOWN. SEE OTHER
INFORMATION.

Lower Limits:1.0
Upper Limits:36
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL. WATER
MAY BE USED TO KEEP FIRE-EXPOSED CONTAINERS COOL UNTIL FIRE IS
OUT.
Fire Fighting Procedures:WEAR A SELF-CONTAINED BREATHING APPARATUS WITH
A FULL FACEPIECE OPERATED IN THE POSITIVE PRESSURE DEMAND MODE WITH
APPROPRIATE TURN-OUT GEAR AND CHEMICAL RESISTANT PERSONAL
PROTECTIVE EQUIPMENT. REFER TO THE PERSONAL PROTECTIVE EQUIPMENT
SECTION OF THIS MSDS.
Unusual Fire/Explosion Hazard:MATERIAL IS HIGHLY VOLATILE AND READILY
GIVES OFF VAPORS WHICH MAY TRAVEL ALONG THE GROUND OR BE MOVED BY
VENTILATION AND IGNITED BY PILOT LIGHTS, OTHER FLAMES, SPARKS,
HEATERS, SMOKING, ELECTRIC MOTO RS, STATIC DISCHARGE, OR OTHER
IGNITION SOURCES AT LOCATIONS DISTANT FROM MATERIAL HANDLING POINT.
NEVER USE WELDING OR

Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION SUCH AS
FLARES, FLAMES (INCLUDING PILOT LIGHTS), AND ELECTRICAL SPARKS.
ABSORB LIQUID ON VERMICULITE, FLOOR ABSORBENT OR OTHER ABSORBENT
MATERIAL. PERSONS NOT WEARING PROPER PERSONAL PEOTECTIVE EQUIPMENT
SHOULD BE EXCLUDED FROM AREA OF SPILL. PREVENT RUN-OFF TO SEWERS,
STREAMS OR OTHER BODIES OF WATER.

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUES (VAPOR, LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS
GIVEN IN THE DATA SHEET MUST BE OBSERV ED. AVOID PROLONGED OR
REPEATED CONTACT.
Other Precautions:DO NOT STORE NEAR EXTREME HEAT, OPEN FLAME, OR
SOURCES OF IGNITION.

Respiratory Protection:IF WORKPLACE EXPOSURE LIMIT(S) OF PRODUCT OR ANY
COMPONENT IS EXCEEDED A NIOSH/MSHA AOORIVED AIR SUPPLIED RESPIRATOR
IS ABVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA
REGULATIONS ALSO PERMIT OTHER NIOSN/MSHA RESPIRATORS (NEGATIVE
PRESSURE TYPE) UNDER SPECIFIED CONDITIONS (CONSULT YOUR INDUSTRIAL
HYGIENIST). (SEE SUPPLEMENTAL DATA).
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:WEAR RESISTAN GLOVES (CONSULT YOUR SAFETY EQUIPMENT
SUPPLIER)
Eye Protection:CHEMICAL SPLASH GOGGLES
Work Hygienic Practices:USE IN A WELL VENTILATED AREA.
Supplemental Safety and Health
ENGINEERING OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOSURE.

HCC:V3
Boiling Pt:=56.1C, 133.F
B.P. Text:FOR COMPONENT
Vapor Pres:185.000 MMHG
Vapor Density:ND
Volatile Org Content %:75
Spec Gravity:.827-.837 @ 77 F
pH:N/D
Appearance and Odor:LIQUID, CLEAR COLORLESS, SOLVENT ODOR
Percent Volatiles by Volume:ND

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH: RACTIVE METALS SUCH AS ALUMINUM AND MAGNESIUM,
STRONG ACIDS, STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:YES
Hazardous Decomposition Products:MAY FORM: CARBON DIOXIDE AND CARBON
MONOXIDE, VARIOUS HYDROCARBONS.
Conditions to Avoid Polymerization:PRODUCT WILL NOT UNDERGO HAZARDOUS
POLYMERIZATION.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE AND FEDERAL REGULATIONS.

Toxicological Information:NO DATA.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NO DATA.

Transport Information:PSN: CONSUMER COMMODITY, ORM-D

SARA Title III Information:SARA 302 COMPONENTS (40CFR 355 APENDIX A):
NONE. SEC 311/312 HAZ CLASS (40CFR 370.2): IMMEDIATE, DELAYED,
FIRE. SARA SEC 313 COMPONENTS (40CFR 372.65): XYLENE 1330-20-7;
METHANOL 67-56-1; ETHYLBENZEN E 100-41-4.
Federal Regulatory Information:THE INTENTIONAL INGREDIENTS ARE LISTED
IN TSCA INVENTORY.
State Regulatory Information:CALIFORNIA PROP 65 STATUS: NONE. NJ AND
PENNSYLVANIA RTK LABEL INFORMATION: XYLENE 1330-20-7; METHANOL
67-56-1; ETHYLBENZENE 100-41-4, ACETONE 67-64-1, CARBON DIOXIDE
100-41-4.