Product ID:COROBOND SECONDARY CONTAINMENT, B60VQ5100, PART B, HARDENER
MSDS Date:07/01/1996
FSC:NIIN:Submitter:N EN
Status Code:A
MSDS Number: CLHKN

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: 54636

Telephone: 800-251-2486/216-566-2242

Cage: 54636

PHENYLMETHANOL

CAS: 100-51-6

RTECS: DN3150000

UNKNOWN)

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ROUTES OF EXPOSURE: EXPOSURE MAY BE BY
INHALATION AND/OR SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF
USE. TO MINIMIZE EXPOSURE, FOLLOW RECOMMENDATIONS FOR PROPER USE,
VENTILATION, AND PERSONAL PRO TECTIVE EQUIPMENT. ACUTE: EFFECTS
OF OVEREXPOSURE: IRRITATION OF EYES, SKIN AND RESPIRATORY SYSTEM.
CHRONIC: RATS EXPOSED TO TITANIUM DIOXIDE DUST AT 250 MG/M3
DEVELOPED LUNG CANCER, HOWEVER, SUCH EXPOSURE LEVELS ARE NOT
ATTAINABLE IN THE WORKPLACE.
Explanation of Carcinogenicity:NO INGREDIENT IN THIS PRODUCT IS AN
IARC, NTP, OR OSHA LISTED CARCINOGEN.
Effects of Overexposure:HEADACHE, DIZZINESS, NAUSEA, AND LOSS OF
COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO VAPORS OR
SPRAY MISTS. REDNESS AND ITCHING OR BURNING SENSATION MAY INDICATE
EYE OR EXCESSIVE SKIN EXPOSU RE.
Medical Cond Aggravated by Exposure:MAY CAUSE ALLERGIC SKIN REACTION IN
SUSCEPTIBLE PERSONS.

First Aid:IF INHALED: IF AFFECTED, REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. IF ON SKIN: WASH AFFECTED AREA
THOROUGHY WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFORE REU SE. IF IN EYES: FLUSH EYES WITH LARGE AMOUNTS OF
WATER FOR 15 MINUTES. GET MEDICAL ATTENTION IMMEDIATELY. IF
SWALLOWED: NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
DO NOT INDUCE VOMITING. G IVE SEVERAL GLASSES OF WATER. GET MEDICAL
ATTENTION IMMEDIATELY.

Flash Point:=103.9C, 219.F
Lower Limits:NOT APPLIC
Upper Limits:NOT APPLIC
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING (NIOSH
APPROVED -) SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED.
WATER SPRAY MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE
PREFERABLE. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT
PRESSURE BUILD-UP AND POSSIBLE AUTOIGNITION (UNUSUAL FIRE &
EXPLOSION HAZARD)
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE (DUE TO THE
BUILDUP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT. FIRE
FIGHTINGH PROCEDURE (CONT): OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT. FLAMMABILITY CLASSIFICA TION: NOT APPLICABLE.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.

Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINERS WITH COMPLETE AND APPROPRIATE
LABELING. DO NOT TAKE INTERNALY. KEEP OUT OF REACH OF CHILDREN.
DOL STORAGE CATEGORY - 3B.
Other Precautions:THIS PRODUCT MAY BE MIXED WITH OTHER COMPONENTS
BEFORE USE. BEFORE OPENING THE PACKAGE, READ AND FOLLOW WARNING
LABELS ON ALL COMPONENTS. READ AND FOLLOW WARNING LABELS ON ALL
COMPONENTS: INTENTIONA L MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, OR WHEN SANDING OR ABRADING THE
DRIED FILM, WEAR A PROPERLY FITTED ORGANIC VAPOR / PARTICULATE
RESPIRATOR APPROVED BY NIOSH FOR PROTECTION AGAINST THE MATERIALS
IN (INGREDIENTS) SECTION. WHEN SANDING OR ABRADING DRIED FILMS,
WEAR A DUST / MIST (SUPPLEMENTAL SAFETY AND HEALTH)
Ventilation:LOCAL EXHAUST PREFERRABLE. GENERAL EXHAUST ACCEPTABLE IF
THE EXPOSURE TO MATERIALS IN (INGREDIENTS) SECTION IS MAINTAINED
BELOW (SUPPLEMENTAL SAFETY & HEALTH)
Protective Gloves:TO PREVENT SKIN CONTACT, WEAR NITRILE RUBBER GLOVES.
Eye Protection:TO PREVENT EYE CONTACT, WEAR (ANSI APPROVED -)
SPLASH-PROOF SAFETY GOGGLES.
Other Protective Equipment:WEAR LONG SLEEVED CLOTHING. USE BARRIER
CREAM ON EXPOSED SKIN. EYEWASH MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:USE ONLY WITH ADEQUATE VENTILATION. AVOID
BREATHING VAPOR AND SPRAY MIST. PREVENT CONTACT WITH SKIN AND EYES.
WASH HANDS AFTER USING. THIS COATING MAY CONTAIN MATERIALS
CLASSIFIED (TOXICOLOGICAL INFO)
Supplemental Safety and Health
PRODUCT IDENTITY: 100% PENETRATING EPOXY PRIMER. RESPIRATORY
PROTECTION (CONT): RESPIRATOR APPROVED BY NIOSH FOR DUST WHICH MAY
BE GENERATED FROM THIS PRODUCT OR THE ABRASIVE. VENTILATIO N
(CONT): APPLICABLE EXPOSURE LIMITS. REFER TO OSHA STANDARDS
1910.94, 1910.107, 1910.108.

Boiling Pt:>148.9C, 300.F
B.P. Text:RANGE
Melt/Freeze Pt:M.P/F.P Text:N.AV.
Vapor Pres:0.2 MMHG (PHENYLMETHANOL)
Vapor Density:> AIR.
Spec Gravity:1.06 - 1.30
VOC Grams/Liter:3.99
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:N.AV.
Appearance and Odor:NOT SPECIFIED BY MFR .

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN. PHOTOCHEMICALLY
REACTIVE: NO.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARON
MONOXIDE, OXIDES OF NITROGEN.

Waste Disposal Methods:WASTE FROM THIS PRODUCT, IF PROPERLY CATALYZED
AND CURED, IS NOT HAZARDOUS AS DEFINED UNDER THE RESOURCE
CONSERVATION AND RECOVERY ACT (RCRA) 40 CFR 261. INCINERATE IN
APPROVED FACILITY. DO NOT INCINE RATE CLOSED CONTAINER. DISPOSE OF
IN ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATIONS REGARDING
POLLUTION.

Toxicological Information:N/P. WORK HYGENIC PRACTICES (CONT): AS
NUISANCE PARTICULATES (LISTED "AS DUST" IN (INGREDIENTS) SECTION)
WHICH MAY BE PRESENT AT HAZARDOUS LEVELS ONLY DURING SANDING OR
ABRADING OF THE DRIED FI LM. IF NO SPECIFIC DUSTS ARE LISTED IN
(INGREDIENTS) SECTION, THE APPLICABLE LIMITS FOR NUISANCE DUSTS ARE
ACGIH TLV 10 MG/M3 (TOTAL DUST), 3 MG/M3 (RESPIRABLE DUST), OSHA
PEL 15 MG/M3 (TOTAL DUST), 5 MG/M3 (RESPIRABLE FRACTION).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

SARA Title III Information:NO INGREDIENT IS SUBJECT TO THE REPORTING
REQUIREMENTS OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT
(SARA) SECTION 313, 40 CFR 372.65 C.
Federal Regulatory Information:TSCA CERTIFICATION: ALL CHEMICALS IN
THIS PRODUCT ARE LISTED, OR ARE EXEMPT FROM LISTING, ON THE TSCA
INVENTORY.