Product ID:MIL-E-24635B #20117
MSDS Date:12/31/1996
FSC:8010
NIIN:01-344-6693
Status Code:A
MSDS Number: CLHYT

SHERWIN-WILLIAMS, SEAGUARD

3560 ELM AVE.
PORTSMOUTH, VA 23704
US

Emergency Phone: 757-397-2223

Info Phone: 757-397-2223

Preparer: HENRY SIMMONS

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

RED IRON OXIDE

CAS: 1332-37-2

RTECS: NO7380000

ACGIH TLV: 10 MG/M3

YELLOW IRON OXIDE PIGMENT

CALCIUM CARBONATE

CAS: 1317-65-3

RTECS: EV9580000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

MAGNESIUM SILICATE

CAS: 14807-96-6

RTECS: WW2710000

OSHA PEL see Table Z-3

ACGIH TLV: 2 MG/M3

MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 2900 MG/M3;500 PPM

ACGIH TLV: 525 MG/M3;100 PPM

AROMATIC 150

CAS: 64742-94-5

RTECS: WF3100000

SUPER HIGH FLASH (S-100)

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Effects of Overexposure:BREATHING OF HIGH VAPOR CONCENTRATIONS MAY
PRODUCE CONCENTRATIONS MAY PRODUCE NARCOSIS. LIQUID MAY CAUSE MINOR
SKIN IRRITATION AND DEFINITE EYE IRRITATION. CAUSES EYE IRRITATION.
CAUSES SKIN IRRITATIO N. REPEATED & PROLONGED NERVOUS SYSTEM
DAMAGE. INTENTION MISUSE BY DELIBERATELY CONCENTRATING & INHALING
CONTENTS MAY BE HARMFUL OR FATAL.

First Aid:INHALATION: REMOVE TO FRESH AIR, RESTORE BREATHING. CONSULT A
PHYSICIAN. SKIN CONTACT: FLUSH WITH WATER. EYE CONTACT: FLUSH
IMMEDIATELY WITH LARGE AMOUNTS OF WATER. CONSULT A PHYSICIAN. FIRST
AID: IF CONTACT: IMMEDIATELY FLUSH EYES OF SKIN WITH PLENTY OF
WATER OF WATER FOR LEAST 15 MIN WHILE REMOVING CONTAMINATED
CLOTHING/SHOES. GET IMMEDIATE MEDICAL ATTENTION. WASH CLOTHING
BEFORE REUSE. DESTROY SHOES. IF SWALLOWED, GET MEDICAL ATTENTION
IMMEDIATELY.

Flash Point Method:SCC
Flash Point:=43.3C, 110.F
Lower Limits:1.0%
Upper Limits:17.8%
Extinguishing Media:WATER FOG, FOAM, CARBON DIOXIDE, DRY CHEMICAL
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED GAS MASK FOR FIRE
FIGHTING PERSONNEL. WATER MAY BE USED TO COOL CONTAINERS. IF WATER
IS USED FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. VAPORS
MAY MIGRATE TO IGNITION SOURCE AND CAUSE FIRE. ISOLATE FROM HEAT,
SPARKS, ELECTRICAL, EQUIPMENT, APPLIANCES, PILOT LIGHTS, FLAMES AND
OTHER SOURCES OF IGNITION. COMBUSTIBLE LIQUID AND VAPOR.

Spill Release Procedures:IN CASE OF SPILLAGE ABSORB WITH INERT MATERIAL
A DISPOSE OF IN ACCORDANCE WITH APPLICABLE REGULATIONS OF EPA AND
OTHER LOCAL, COUNTY, STATE, AND FEDERAL REGULATIONS.

Handling and Storage Precautions:STORE AWAY FROM HEAT, SPARKS, AND OPEN
FLAME. AVOID PROLONGED SKIN CONTACT. DO NOT BREATHE SPRAY MIST.
STORE IN A COOL DRY AREA WITH VENTILATION SUITABLE FOR STORING
MATERIALS SHOWN IN SECTION II.
Other Precautions:GROUND CONTAINERS WHILE POURING. AVOID SPONTANEOUS
COMBUSTION OF CONTAMINATED RAGES OR OTHER ORGANIC MATERIALS. EMPTY
CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES AND CAN BE DANGEROUS.

Respiratory Protection:NIOSH/OSHA APPROVED RESPIRATOR TYPES SUITABLE
FOR MATERIALS IN SECTION II RECOMMENDED. APPROVED
CHEMICAL/MECHANICAL FILTER RECOMMENDED WHEN VENTILATION IS
RESTRICTED. DO NOT BREATHE (DUST, VAPORS OR S PRAY MIST). WEAR
APPROPRIATE, RESPIRATOR TYPES SUITABLE DURING & AFTER APPLICATION
UNLESS AIR MONITORING RECORDS VAPOR/MIST LEVELS BELOW APPLICABLE
LIMITS.
Ventilation:SUFFICIENT VENTILATION, IN VOLUME AND PATTERN, SHOULD BE
PROVIDE TO KEEP AIR CONTAMINATION BELOW CURRENT APPLICABLE OSHA
PERMISSIBLE EXPOSURE LIMIT.
Protective Gloves:CHEMICAL RESISTANT PLASTIC OR RUBBER.
Eye Protection:CHEMICAL GOGGLES WITH SIDE SHIELDS OR FACE SHIELD
RECOMMENDED.
Other Protective Equipment:AS REQUIRED TO AVOID GETTING TO AVOID
WETTING CLOTHING. USE PROTECTIVE CREAMS WHERE SKIN CONTACT IS
LIKELY. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE. EYE
BATH AND SAFETY SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES, SKIN, AND CLOTHING.
WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health

Boiling Pt:=111.1C, 232.F
B.P. Text:232-401F
Vapor Density:>AIR
VOC Pounds/Gallon:339
VOC Grams/Liter:2.83
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID AND A SOLVENT ODOR
Percent Volatiles by Volume:24.8%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OR OPEN FLAME

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, COUNTY, STATE, AND FEDERAL AUTHORITIES.

SARA Title III Information:108-88-3, TOLUENE, 1% MAX; 1330-20-7,
XYLENE, 1% MAX; 95-63-6, 1,2,4-TRIMETHYLBENZENE, 8% MAX.; COBALT
COMPOUND, .2% BY WEIGHT.
State Regulatory Information:SARA 313 (40 CFR 372.65 C) SUPPLIER
NOTIFICATION

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.