Product ID:INTERLAC 1 HAZE GRAY 45587A
MSDS Date:08/24/1999
FSC:8010
NIIN:01-441-6151
Status Code:A
MSDS Number: CLNDJ

COURTAULDS COATINGS INC. INTERNATIONAL

6001 ANTOINE DRIVE
HOUSTON, TX 77091
US

Emergency Phone: 800-854-6813

Info Phone: 713-684-1563

Preparer: ERNEST CARTER

Cage: 028S6

INTERNATIONAL PAINT INC

HOUSTON, TX 77091 US

Telephone: 713-684-1244

Cage: 028S6

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3

ACGIH TLV: 10 MG/M3

ETHYLBENZENE

CAS: 100-41-4

RTECS: DA0700000

OSHA PEL 435 MG/M3;100 PPM

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

1,2,4-TRIMETHYLBENZENE

CAS: 95-63-6

RTECS: DC3325000

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

AMORPHOUS SILICA

CAS: 7631-86-9

AROMATIC HYDROCARBONS

CAS: 64742-95-6

RTECS: WF3400000

TRIMETHYLBENZENE

CAS: 25551-13-7

RTECS: DC3220000

ACGIH TLV: 123 MG/M3;25 PPM

MAGNESIUM SILICATE HYDRATE

CAS: 14807-96-6

RTECS: WW2710000

OSHA PEL see Table Z-3

ACGIH TLV: 2 MG/M3

AMORPHOUS PRECIPITATED SILICA

CAS: 112926-00-8

RTECS: VV7315000

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 10 MG/M3

ALUMINUM HYDROXIDE

CAS: 21645-51-2

RTECS: BD0940000

N-BUTYL ALCOHOL

CAS: 71-36-3

RTECS: EO1400000

OSHA PEL 300 MG/M3;100 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

FERRIC OXIDE

CAS: 1309-37-1

RTECS: NO7400000

OSHA PEL 10 MG/M3

ACGIH TLV: 5 MG/M3;2 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: VAPOR HARMFUL. MAY AFFECT
THE BRAIN OR NERVOUS SYSTEM CAUSING DIZZINESS, HEADACHE OR
NAUSEA.MILDLY TOXIC BY INHALATION. CAUSES NOSE AND THROAT
IRRITATION.EYE CONTACT: CAUSES EYE IRRITATION . SKIN CONTACT: CAN
BE ABSORBED THROUGH THE SKIN. MAY CAUSE ORGAN DAMAGE.CAUSES SKIN
IRRITATION. INGESTION: MAY BE FATAL IF SWALLOWED AND MAY CAUSE
ORGAN DAMAGE.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF DISCOMFORT IS PRESENT OR
BREATHING IS ABSENT GET MEDICAL ATTENTION IMMEDIATELY.EYE CONTACT:
FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR 15 MINUTES UNTIL
IRRITATION SUBSIDES.IF IRRITATION PERSISTS, GET MEDICAL ATTENTION.
SKIN CONTACT: FLUSH WITH LARGE AMOUNTS OF WATER.USE SOAP IF
AVAILABLE.REMOVE SEVERELY CONTAMINATED CLOTHING (INCLUDING SHOES)
AND WASH BEFORE RE USE. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. INGESTION: IF SWALLOWED, DO NOT INDUCE VOMITING. KEEP AT
REST. GET PROMPT MEDICAL ATTENTION

Flash Point Method:CALC
Flash Point:=40.C, 104.F
Autoignition Temp:Autoignition Temp Text:NONE
Lower Limits:.5%
Upper Limits:NONE
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, SPARKS, ELECTRICAL
EQUIPMENT AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. IN THE ABSENCE OF ELECTRICITY, A WATER
SPRAY (FOG NOZZLE PREFERRED) MAY BE U SED TO COOL CONTAINERS.
DECOMPOSITION PRODUCTS MAY BE TOXIC.

Spill Release Procedures:CONTAIN SPILLED LIQUID WITH SAND OR EARTH.DO
NOT USE COMBUSTIBLE MATERIALS SUCH AS SAWDUST. ABSORB SPILL WITH AN
INERT MATERIAL THEN PLACE IN A CHEMICAL WASTE CONTAINER.

Handling and Storage Precautions:KEEP CONTAINER CLOSED. LOOSEN CLOSURE
CAUTIOUSLY BEFORE OPENING. STORE IN A COOL, WELL VENTILATED PLACE
AWAY FROM INCOMPATIBLE MATERIALS. KEEP AWAY FROM HEAT, SPARKS AND
FLAMES. PROTECT MATERIAL FROM DIRECT SUNLIGHT. GROUND AND BOND
CONTAINERS WHEN TRANSFERRING MATERIALS. EMPTY CONTAINERS MAY RETA

Respiratory Protection:DO NOT BREATHE VAPORS OR SPRAY MIST. IF YOU
EXPERIENCE EYE WATERING, HEADACHE OR DIZZINESS OR IF AIR MONITORING
DEMONSTRATES VAPOR/MIST LEVELS ARE ABOVE APPLICABLE LIMITS, WEAR AN
APPROPRIATE, PROPERL Y FITTED RESPIRATOR (NIOSH APPROVED) DURING
AND AFTER APPLICATION. .
Ventilation:PROVIDE SUFFICIENT VENTILATION.
Protective Gloves:WEAR CHEMICAL RESISTANT GLOVES.
Eye Protection:SAFETY GLASSES, CHEMICAL GOGGLES AND/OR A FACE SHIELD
Other Protective Equipment:CLOTHING: AS NEEDED, USE BODY PROTECTION TO
AVOID CONTACT WITH PRODUCT.
Supplemental Safety and Health

Boiling Pt:=63.9C, 147.F
Melt/Freeze Pt:M.P/F.P Text:NONE
Decomp Temp:Decomp Text:NONE
Vapor Density:HEAVIER
Spec Gravity:1.381
Evaporation Rate & Reference:SLOWER/ETHER
Appearance and Odor:LIQUID

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION AS IN WELDING. FUMES MAY PRODUCE CARBON
DIOXIDE AND CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.

Toxicological Information:THERE IS NO DATA AVAILABLE ON THE PRODUCT
ITSELF. CONTAINS 1,2,4-TRIMETHYL BENZENE WHICH CAN CAUSE CENTRAL
SYSTEM DEPRESSION, ANEMIA AND BRONCHITIS. NOTICE: REPORTS HAVE
ASSOCIATED REPEATED AND PROLON GED OCCUPATIONAL OVEREXPOSURE TO
SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. ITENTIONAL
MIUSE BY DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY
BE HARMFUL OR FATAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:THERE IS NO DATA AVAILABLE ON THE PRODUCT ITSELF.

Transport Information:DOT (DEPARTMENT OF TRANSPORATION) PROPER SHIPPING
NAME: PAINT HAZARD CLASS: FLAMMABLE LIQUID, 3 UN NUMBER: UN1263
PACKING GROUP: PACKING GROUP III

SARA Title III Information:NONE KNOWN UNLESS CHEMICALS ARE SPECIFIED
BELOW. SECTION 302 REPORTABLE INGREDIENTS 313 REPORTABLE
INGREDIENTS 000071-36-3 N-BUTYL ALCOHOL 000095-63-6
1,2,4-TRIMETHYLBENZENE 000100-41- 4 ETHYBENZENE
001330-20-7 XYLENE.
Federal Regulatory Information:TSCA (TOXIC SUBSANCE CONTROL ACT)
COMPONENTS OF THIS PRODUCTS ARE LISTED ON THE TSCA INVENTORY. CERLA
(COMPREHENSION RESPONSE COMPENSATION, AND LIABILITY ACT): WE
RECOMMEND YOU CONTACT LOCAL AUTHORITE S TO DETERMINE IF THESE MAY
BE OTHER LOCAL REPORTING REQUIREMENTS.
State Regulatory Information:CALIFORNIA PROPOSITION 65: NONE KNOWN
UNLESS SPECIFED BELOW. WARNING: THIS PROUCT CONTAINS A CHEMICAL
KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM. WARNING: THIS PRODUCT CONTAINS A CHEMICAL
KNOWN TO THE STATE OF CALLIFORNIA TO CAUSE CANCER.