Product ID:SILVER-BRITE ALUMINUM PAINT B59 S 11
MSDS Date:05/29/1998
FSC:8010
NIIN:00-815-2692
Status Code:A
MSDS Number: CLRQS

Emergency Phone: 216-566-2917

Info Phone: 800-251-2486/216-566-2242

Preparer: ERNEST CARTER

Cage: 54636

Telephone: 800-251-2486/216-566-2242

Cage: 54636

MEDIUM ALIPHATIC SOLVENT NAPHTHA (PETROLEUM)

CAS: 64742-88-7

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL see Table Z-2

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:EXPOSURE MAY BE BY INHALATION AND/OR
SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF USE. TO MINIMIZE
EXPOSURE, FOLLOW RECOMMENDATIONS FOR PROPER USE, VENTILATION, AND
PERSONAL PROTECTIVE EQUIPMENT. C OBALT AND COBALT COMPOUNDS ARE
CLASSIFIED BY IARC AS POSSIBLY CARCINOGENIC TO HUMANS (GROUP 2B)
BASED ON EXPERIMENTAL ANIMAL DATA, HOWEVER, THERE IS INADEQUATE
EVIDENCE IN HUMANS FOR ITS CARCINOGENICI TY.PROLONGED OVEREXPOSURE
TO SOLVENT INGREDIENTS IN SECTION 2 MAY CAUSE ADVERSE EFFECTS TO
THE LIVER, URINARY, CARDIOVASCULAR AND RPRODUCTIVE SYSTEMS.
Effects of Overexposure:IRRITATION OF EYES, SKIN AND RESPIRATORY
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE
MAY RESULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH. HEADACHE,
DIZZINESS, NAUSEA, AND LOSSS OF C OORDINATION ARE INDICATIONS OF
EXCESSIVE EXPOSURE TO VAPORS OR SPRAY MISTS. REDNESS AND ITCHING OR
BURNING SENSATION MAY INDICATE EYE OR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:NONE GENERALLY RECOGNIZED.

First Aid:IF INHALED: IF AFFECTED REMOVE FROM EXPOSURE. RESTORE
BREATHING. KEEP WARM AND QUIET. IF ON SKIN: WASH AFFECTED AREA
THOROUGHLY WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFORE RE- USE. IF IN EYES: FLUSH EYES WITH LARGE AMOUNTS
OF WATER FOR 15 MINUTES. GET MEDICAL ATTENTION. IF SWALLOWED:
B59S3==> NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. DO
NOT INDUCE VOMITING. GIV E CONSCIOUS PATIENT SEVERAL GLASSES OF
WATER. SEEK MEDICAL ATTENTION.

Flash Point:=35.C, 95.F
Lower Limits:0.7%
Upper Limits:7.0%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING SELF
CONTAINED BREATHING APPARATUS SHOULD BE USED. WATER SPRAY MAY BE
INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. WATER
MAY BE USED TO COOL CLOSED CO NTAINERS TO PREVENT PRESSURE BUILD UP
AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT. ELECTRICAL EQUIPMENT, SPARKS, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO
HOT SURFACES REQUIRES SPECIA L PRECAUTIONS. DURING EMERGENCY
CONDITIONS OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A
HEALTH HAZARD.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.

Handling and Storage Precautions:DURING USE AND UNTIL ALL VAPORS ARE
GONE: KEEP AREA VENTILATED DO NOT SMOKE EXTINGUISH ALL FLAMES,
PILOT LIGHTS, AND HEATERS TURN OFF STOVES. ELECTRIC TOOLS AND
APPLICANCES, AND ANY OTHER SOURCES OF I GNITION. CONSULT NFPA CODE.
USE APPROVED BONDING AND GROUNDING PROCEDURES. KEEP CONTAINER
CLOSED WHE
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLCABLE LIMITS BY VENTILATION. WEAR A PROPERLY FITTED ORGANIC
VAPOR/PARTICULATE RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION
AGAINST MATERIALS IN SECTION 2. WHEN SANDING OR ABRADING THE DRIED
FILM, WEAR A DUST/MIST RESPIRATOR APPROVED BY NIOSH/MSHA FOR DUST
WHICH MAY BE GENERATED FROM THIS PRODUCT, UNDER
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF THE
EXPOSURE TO MATERIALS IN SECTION 2 IS MAINTAINED BELOW APPLICABLE
EXPOSURE LIMITS.
Protective Gloves:WEAR GLOVES WHICH ARE RECOMMENDED BY GLOVE AUPPLIER
FOR PROTECTION
Eye Protection:WEAR SAFETY SPECTACLES WITH UNPERFORATED SIDESHIELDS.
Supplemental Safety and Health

HCC:F2
Boiling Pt:B.P. Text:222-425 F
Vapor Density:HEAVIER
Spec Gravity:0.90-1.09
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:58-79%

Stability Indicator/Materials to Avoid:YES
CONTAMINATION WITH WATER, ACIDS. OR ALKALIS CAN CAUSE EVOLUTION OF
HYDROGEN, WHICH MAY RESULT IN DANGEROUSLY INCREASED PRESSURES IN
CLOSED CONTAINERS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:WASTE FROM THESE PRODUCTS MAY BE HAZARDOUS AS
DEFINED UNDER THE RESOURCE CONSERVATION AND RECOVERY ACT (RCRA) 40
CFR 261. WASTE MUST BE TESTED FOR IGNITABILITY, TO DETERMINE THE
APPLICABLE EPA HAZARDO US WASTE NUMBER. INCINERATE IN APPROVED
FACILITY. DO NOT INCINERATE CLOSED CONTAINER. DISPOSE OF IN
ACCORDANCE WITH FEDERAL, STATE, AND LOCAL REGULATI

Toxicological Information:IMMEDIATE (ACUTE) EFFECTS: NO ACUTE EFFECTS
HAVE BEEN IDENTIFIED. DELAYED (SUBCHRONIC AND CHRONIC) EFFECTS: NO
DELAYED OR CHRONIC EFFECTS HAVE BEEN IDENTIFIED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:THESE MATERIALS ARE CHEMICALLY UNREACTIVE, NON-TOXIC,
NON-WATER SOLUBLE, AND NON-BIODEGRADABLE.

Transport Information:US DOT HAZARD CLASS: NOT APPLICABLE.

SARA Title III Information:SARA TITLE III/CERCLA: "REPORTABLE
QUANTITIES" (RQS) AND/ OR "THRESHOLD PLANNING QUANTITIES" (TPQS)
EXIST FOR THE FOLLOWING INGREDIENTS: NOT APPLICABLE. SARA 313 TOXIC
CHEMICALS: THIS PRODUCT CONTAINS THE FOLLOWING CHEMICALS SUBJECT
TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III OF THE
EMERGENCY PLANNING AND COMMUNITY RIGHT TO KNOW ACT OF 1986 AND OF
40 CFR 372: NONE.
Federal Regulatory Information:TOXIC SUBSTANCE CONTROL ACT (TSCA): TSCA
INVENTORY STATUS: ALL COMPONENTS ARE LISTED IN THE TSCA INVENTORY.